Professional Documents
Culture Documents
Synchronized Package Proposal 2 MW
Synchronized Package Proposal 2 MW
Synchronized Package Proposal 2 MW
0 MW (2500KVA)
AGN Technology offers the full and complete 2.0 MW of electricity package as a turnkey solution. The enter
package shall be install and test for client by AGN Technology engineering department.
Package Price for Grid Connected 2.0 MW Synchronized Electricity: Call For Details Price
**Note: Synchronized 5 generator (Diesel Engine) and through power to one common bas-bar.
Payment Terms:
60% advance along with at the time of contract singing, Balance 30% payment after delivery materials to site
and remaining 10% will be payment at the time of project handover to the client.
Material Transportation:
Inside UAE:
Transport all material from AGN Technology warehouse (in UAE) to site location is including with package
price.
Outside UAE:
Transport all material from AGN Technology warehouse (in UAE) to site location is the client responsibility.
Price Change:
All Price are subject to change and alternation without prior notice. Should the prices changes during the
contract, AGN will not change price for existing client contract.
Sf6 RMU
TO LOAD TO LOAD Capacity: 630A
CT Ratio: 100:1
With Over current &
Earth fault protection
4000A/5A
CT
Computerized Synchronization
Control Panel
Computerized
Synchronization MCCB 1000A,4P,50KA
control panel 1000/5A WITH SCC, OC PROTECTION
WITH MOTOR OPERATOR
1000/1A
CT CT CT CT 1000/5A
GEN- 1
GEN- 2
GEN- 5
G EN- 3
GEN- 4
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
SYNCHRONIZATION CONTROL PANEL SPECIFICATION
LOAD PROPERTIES:
Automatic and manual synchronization
Can synchronized until 10 generators among
them selves and feed the workload
Load sharing at generators according to power
Automatically start and stop according to load
Automatically balancing work hours (co-aging)
COMMUNICATION PROPERTIES:
Communication over (AQ) bus-bar with
electronic engine control units (optional)
Alarm message with SMS (optional)
Open communication over RS 232 or RS 485 interface
Support Motbus RTU protocol (concordant with scada system)
INDICATOR PROPERTIES:
LCD text indicator
All engine and alternator parameters can be watched
Engine and alternator protection
Keep the records of generator alarms, last 25 records
Expansion modules (in and out)
With LCD screen in ATSP09 synchronization panels you can measure the following rates and with the stated protection,
system reliability put in first place.
MEASUREMENTS:
DIRECT MEASURES:
Oil pressure
Coolant temperature
Fuel level (optional)
Oil temperature (optional)
Accumulator voltage
Engine circulation
Generator frequency
Generator phase-neutral voltage
Generator inter-phase voltage
Generator phase current
Generator earth current (optional)
Generator phase sequence
EXPANDABLE MEASUREMENTS:
Generator total active power (KW)
Generator total visible power (KVA)
Generator total reactive power (KVAr)
Generator average power factor (cos)
HIDDEN MEASUREMENTS:
Actual time
Left time for the next (maintenance)
Generator positive KWh
Generator negative KWh
Generator KVAh
Generator KVArh
Number of starter
Maximum positive vector slide
Maximum negative vector slide
PROTECTION SYSTEM:
ENGINE PROTECTION:
Low oil pressure
High coolant water temperature
High oil temperature (optional)
Low/high frequency cycle
Battery charger rectifier error
Low/high accumulator voltage
Low/high fuel level (optional)
ALTERNATOR PROTECTION:
Low/high voltage
Low/high frequency
Extreme voltage
Earthling error (optional)
Reverse power
Wrong phase rotation of alternator
Excitation loss
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
MCCB TECHNICAL SPECIFICATION
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
AIR CIRCUIT BREAKER SPECIFICATION
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
STEP- UP POWER TRANSFORMER SPECIFICATION
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
SF6 RMU TECHNICAL DETAILS
2 nos of 630Amp triple pole, single break, 3- position (ON, OFF and
EARTH) ring main switches, each with independent manually charged
spring mechanism and fully rated earth switch with provision for earth
and test of the cable.
2 nos of air insulated cable boxes and cable clams suitable for a 3 core
cable up to 300mm.
1 no 250 Amps triple pole, vacuum circuit breaker, with independent
manually charged spring mechanism and fully rated earth switch with
provision for earth and test of the cable.
1 no air insulated cable box and clamp suitable for a 3- core cable up to
185mm.
1 no mimic diagram on front panel, complete with status indicator.
1 set of positive standard mechanical interlocks.
1 set of current transformer for relay protection.
1 no ABEVA make self powered relay type: MICOM P124 for O/C & E/F
protection.
1 no 24V DC shunt trip coil for remote tripping of circuit breaker.
1 set of fully interlocked test access cover.
2 nos of neon indicator lamps /phase comparator sockets for each ring
switch.
1 no stud for earthling connection.
1 no pressure indicator and SF6 recharging facility.
1 no PULL TO TRIP mechanism (Suitable shrouded).
1 set of auxiliary terminal.
1 no operating handle.
1 no earth fault indicator, electrical Auto reset (240V AC), complete with
solid core current transformer.
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
VACUUM CIRCUIT BREAKER (VCB) TECHNICAL SPECIFICATIONS
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
LOW VOLTAGE CABLE TECHNICAL DETAILS
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable
FUEL TANK DESIGN SPECIFICATION
Technical information and values are according to ISO8528, ISO3046, NEMA MG1.22, IEC 600341, BS 49995000, VDE 0530 standards. All products manufactured according to ISO9001, ISO14001, OHSAS18001, TSE, CE
standards. All information given in this specification set is intended for general purposes only. Due to a policy continuous improvement AGN Technology reserves the right to amend details and specifications without
notice and all information given is subject to the AGN Technology current condition of sales.
TBA: To Be Ask TBD: To Be Determined NA: Not Available N/A: Not Applicable