Professional Documents
Culture Documents
AvaraDynaFlexTraining VIU v2
AvaraDynaFlexTraining VIU v2
In the following text the word Publication means the contained text and all appendices, attachments, enclosures,
inclusions and drawings, and the word Avara refers to Avara Technologies Pty Ltd.
This publication is Commercial in Confidence. Avara is the owner of the copyright in this publication. This
publication was published by Avara in Australia in October 2014. No part of this publication may be copied,
distributed, transmitted, transcribed, stored in a retrieval system or translated into any human or computer language
without the prior written authorisation of Avara.
DISCLAIMER
Avara has made every effort to ensure that the instructions contained in the documents are adequate and free from
errors and omissions. The documents have been prepared to be used by professional and properly trained personnel
and the customer assumes full responsibility when using them. Avaras liability for any errors in the documents is
limited to the correction of errors.
Avara if necessary will explain issues that may be covered by the documents.
Avara welcomes customer comments as part of the process of continuing development and improvement of the
documentation in the best possible way for the users viewpoint.
The Licensee is granted a license to modify and translate this publication to meet their needs in providing
training to the Licensees customers on Avaras Product(s) covered by this document.
The Licensee will not acquire any right, title or interest in the Intellectual Property contained in this publication
which remains the property of Avara Technologies.
RED RED
RED
YELLOW YELLOW
YELLOW
GREEN GREEN
GREEN
a c a c
a c
FXS 7 Tip7 a32 c32 Ring 7 FXO 7 Tip7 a32 c32 Ring 7
a31 c31 a31 c31 E2_5 (OUT) a32 c32 E2_RET_5 (OUT)
a30 c30 a30 c30 E1_5 (OUT) a31 c31 M1_5 (IN)
FXS 8
FXS 1
Tip8
Tip1
a29
a28
a27
a26
c29
c28
c27
c26
Ring 8
Ring 1
FXO 8
FXO 1
Tip8
Tip1
a29
a28
a27
a26
c29
c28
c27
c26
Ring 8
Ring 1
VF Cha nnel 5 M2_5 (IN)
Tx_a5 (IN)
a30
a29
a28
Rx_a5 (OUT) a27
c30
c29
c28
c27
M2_RET_5 (IN)
Tx_b5 (IN)
Rx_b5 (OUT)
Voice Interface Unit Part No.
a25 c25 a25 c25 E2_6 (OUT) a26 c26 E2_RET_6 (OUT)
a24 c24 a24 c24 E1_6 (OUT) a25 c25 M1_6 (IN)
a23 c23 a23 c23 M2_6 (IN) a24 c24 M2_RET_5 (IN)
VF Cha nnel 6
FXO P61022.01
a22 c22 a22 c22 Tx_a6 (IN) a23 c23 Tx_b6 (IN)
FXS 2 Tip2 a21 c21 Ring 2 FXO 2 Tip2 a21 c21 Ring 2 a22 c22
a20 c20 a20 c20 Rx_a6 (OUT) a21 c21 Rx_b6 (OUT)
a19 c19 a19 c19 a20 c20
a18 c18 a18 c18 a19 c19
a17 c17 a17 c17 a18 c18
a16 c16 a16 c16 a17 c17
a15 FXO 3 Tip3 a15 c15 Ring 3 a16 c16
FXS P61023.01
FXS 3 Tip3 c15 Ring 3
a14 c14 a15 c15
a14 c14
E2_7 (OUT) a14 c14 E2_RET_7 (OUT)
a13 c13 a13 c13
a12 E1_7 (OUT) a13 c13 M1_7 (IN)
a12 c12 c12
M2_7 (IN) a12 c12 M2_RET_7 (IN)
a11 c11 a11 c11 VF Cha nnel 7 Tx_a7 (IN) a11 c11 Tx_b7 (IN)
a10 c10 a10 c10
a10 c10
FXS 4 Tip4 a9 c9 Ring 4 FXO 4 Tip4 a9 c9 Ring 4 Rx_a7 (OUT) a9 c9 Rx_b7 (OUT)
a8 c8 a8 c8 a8
P1 P1 P2
P1
a c
Rx_b1 (OUT)
E2_RET_2 (OUT)
Rx_an and Rx_bn =
4-wire RX signals OUT
for channel n from backplane
The Avara DynaFlex VIU VF8 E&M 8Ch Voice
Interface (P61021.01) is the equivalent of the
E1_2 (OUT) a25 c25 M1_2 (IN) Tx_an and Tx_bn =
M2_2 (IN) a24 c24 M2_RET_2 (IN)
VF Cha nnel 2 Tx_a2 (IN) a23 Tx_b2 (IN) 4-wire TX signals IN
c23
a22 c22 for channel n to backplane
Rx_a2 (OUT) a21 c21 Rx_b2 (OUT)
a20 c20
a19
a18
a17
a16
a15
c19
c18
c17
c16
c15
E & M Signals:
Ex_n = E Wire signal OUT
x = 1 or 2, two E signals per interface.
Dynanet E&M/VF P, 8Ch (TU 21236).
E2_3 (OUT) a14 c14 E2_RET_3 (OUT)
E1_3 (OUT) a13 c13 M1_3 (IN)
Mx_n = M Wire signal IN
VF Cha nnel 4
M2_4 (IN)
Tx_a4 (IN)
Rx_a4 (OUT)
a6
a5
a4
a3
a2
c6
c5
c4
c3
c2
M2_RET_4 (IN)
Tx_b4 (IN)
Rx_b4 (OUT)
subscriber exchange unit that provides
connectivity for up to 8 subscribers end
GND a1 c1 GND
RED
YELLOW
telephones to an analogue exchange
a c
GREEN
The VF8 (P61033.02) is configurable for 2W or
VF Cha nnel 5
E2_5 (OUT)
E1_5 (OUT)
M2_5 (IN)
a32
a31
a30
c32
c31
c30
E2_RET_5 (OUT)
M1_5 (IN)
M2_RET_5 (IN)
4W operation with configurable 2W
Tx_a5 (IN) a29 c29 Tx_b5 (IN)
a28
Rx_a5 (OUT) a27
E2_6 (OUT) a26
E1_6 (OUT) a25
M2_6 (IN) a24
c28
c27
c26
c25
c24
Rx_b5 (OUT)
E2_RET_6 (OUT)
M1_6 (IN)
M2_RET_5 (IN)
impedance.
VF Cha nnel 6 Tx_a6 (IN) a23 Tx_b6 (IN)
c23
a22 c22
VF Cha nnel 7
a15
E2_7 (OUT) a14
E1_7 (OUT) a13
M2_7 (IN) a12
Tx_a7 (IN) a11
c15
c14
c13
c12
c11
E2_RET_7 (OUT)
M1_7 (IN)
M2_RET_7 (IN)
Tx_b7 (IN)
G.711 and G.712.
a10 c10
Rx_a7 (OUT) a9 c9 Rx_b7 (OUT)
E2_8 (OUT) a8 c8 E2_RET_8 (OUT)
E1_8 (OUT) a7 c7 M1_8 (IN)
M2_8 (IN) a6 c6 M2_RET_8 (IN)
VF Cha nnel 8 Tx_a8 (IN) a5 c5 Tx_b8 (IN)
a4 c4
Rx_a8 (OUT) a3 c3 Rx_b8 (OUT)
a2 c2
GND a1 c1 GND
P2
9 Avara Technologies. All rights reserved. Document Number: D14100602
Signalling
E1 & M1
E M1_n
M TS16
M
IN a bit
Detector INV M
Tx 2Mbit/s (PCM30)
1 TS16
E Switch Debouncing
M E1_n Control FREEZE Filter
Pin E= a
Rx 2Mbit/s (PCM30)
E = a INV TS16
E
OUT open
Switch
closed
E2 & M2
E M2_n
M TS16
M
IN b bit
Detector INV M
Tx 2Mbit/s (PCM30)
1 TS16
M2_RET_n **
0
Pin Jumper
M1 transmitted through b bit
-12V
E Switch Debouncing
M E2_n Control FREEZE Filter
Pin E= b
Rx 2Mbit/s (PCM30)
E = b INV TS16
E
OUT open
Switch
closed
E2_RET_n **
E2 received from b bit
-Ubatt Pin
GND
2ms 2ms
Filter Window
P1 P1
M2_n E2_n
Jumpers Jumpers
J25
1
J20
J22
2
J17
J19
Red
3 J15
Yellow J16
Green
4 J13
J13
5
J8
J10
6
J5
P2 J7
7 J3
J4
8 J1
E M2_n Pin
M E2_n Pin
Jumper
E2_RET_n
Pin
5 Step Process
Install the channel card
Assign timeslots to the channels on the card
Configure the interfaces on the channel card
Determine status of the interfaces on the channel card
Verify interface & circuit status on the channel card
VF8
TX RX TSn Out
Serial
Interface
1 2 2Mbit/s
RX TX TSn in
To ensure a loopback is not left in place, set the timeout timer has been using the following:
Q1 menu command: m: 6,9,u,6,1..32767
Or the CLI command: Slot_n % config system lbtimeout [1..32767]
The Avara DynaFlex VIU FXO Voice (P61022.01) is the equivalent of the Dynanet
Sub/Exch 6Ch (TU 21216).
NIU
The VIU FXO (P61022.01) is an 8 channel subscriber exchange unit that
provides connectivity for up to 8 subscribers end telephones to an analogue
exchange
All FXO (P61022.01) channels are or have:
RED Configurable 2W balanced impedance
YELLOW
a22 c22
FXO 2 Tip2 a21
a20
a19
a18
c21
c20
c19
Ring 2
Coupling Transformers for the TX and RX are interfaces.
c18
a17 c17
a16 c16
P1
Functional Description
Each voice channel has its own codec to perform the A/D and D/A function, the voice having been converted to
PCM and digital encoded then mapped to a selected 64kbit/s timeslot on the DB4/DB4X.
Tip PCM
IN/OUT CODEC
Ring TX/RX 64kbit/s
Timeslot
Signalling
Hook Switch ABCD CAS
Ring Detect
Typical Application
PABX/Office End
FXS D D FXO
B B
4 G.704 2Mbit/s 4
Subscriber End
5 Step Process
Install the channel card
Assign timeslots to the channels on the card
Configure the interfaces on the channel card
Determine status of the interfaces on the channel card
Verify interface & circuit status on the channel card
Backplane Bus
TX RX TSn Out
CODEC 2Mbit/s
RX TX TSn in
To ensure a loopback is not left in place, set the timeout timer has been using the following:
Q1 menu command: m: 6,9,u,6,1..32767
Or the CLI command: Slot_n % config system lbtimeout [1..32767]
25 Avara Technologies. All rights reserved. Document Number: D14100602
FXS Subscriber End
Channel Card
DynaFlex Voice Interface Units
P1
Typical Application
PABX/Office End
FXS D D FXO
B B
4 G.704 2Mbit/s 4
Subscriber End
Each voice channel has its own codec to perform the A/D and D/A function, the voice having been converted to
PCM and digital encoded then mapped to a selected 64kbit/s timeslot on the DB4/DB4X.
Tip
IN/OUT Hydbrid PCM
Ring
SLIC
5 Step Process
Install the channel card
Assign timeslots to the channels on the card
Configure the interfaces on the channel card
Determine status of the interfaces on the channel card
Verify interface & circuit status on the channel card
Backplane Bus
TX RX TSn Out
CODEC 2Mbit/s
RX TX TSn in
To ensure a loopback is not left in place, set the timeout timer (Default 10 min) has been using the following:
Q1 menu command: m: 6,9,u,6,1..32767
Or the CLI command: Slot_n % config system lbtimeout [1..32767]
32 Avara Technologies. All rights reserved. Document Number: D14100602
Firmware Download
DynaFlex Channel Cards
Determine
1
Firmware
Versions
2 Download
Firmware to
Channel Card
Download Firmware from a
remote TFTP server
SW Image 1:
(active)
Each channel card has 2
memory banks
available for firmware
to be loaded
SW Image 2:
(backup)
Command:
install slot <N> <ip_address> filename
2 Download
Firmware To
Channel Card
SW Image 1:
(active)
tftp
Server
SW Image 2:
(backup)
192.168.1.2
CLI Command:
SW Image 1:
(active)
tftp
Server
Downloading
SW Image 2:
(backup)
192.168.1.2
CLI Command: