Professional Documents
Culture Documents
Agency Approvals Braided 2651 - BV
Agency Approvals Braided 2651 - BV
www.veristar.com
Requirements:
BUREAU VERITAS Rules for the Classification of Steel Ships
BUREAU VERITAS Rules for the Classification of Offshore Units
This certificate is issued to attest that BUREAU VERITAS did undertake the relevant approval procedures for the product identified above which
was found to comply with the relevant requirements mentioned above.
This certificate remains valid until the date stated above, unless cancelled or revoked, provided the conditions indicated in the subsequent page(s) are complied
with and the product remains satisfactory in service. This certificate will not be valid if the applicant makes any changes or modifications to the approved product,
which have not been notified to, and agreed in writing with BUREAU VERITAS. Should the specified regulations or standards be amended during the validity of
this certificate, the product(s) is/are to be re-approved prior to it/they being placed on board vessels to which the amended regulations or standards apply. This
certificate is issued within the scope of the General Conditions of BUREAU VERITAS Marine & Offshore Division available on the internet site www.veristar.com.
Any Person not a party to the contract pursuant to which this document is delivered may not assert a claim against BUREAU VERITAS for any liability arising out
of errors or omissions which may be contained in said document, or for errors of judgement, fault or negligence committed by personnel of the Society or of its
Agents in establishment or issuance of this document, and in connection with any activities for which it may provide.
1. PRODUCT DESCRIPTION
Rubber Hoses Type 2651/2652, FC195 and 150901
End fittings: - Medium Pressure series for Type 2651/2652
- Crimp fittings series for Type FC195 and 150901
3. TEST REPORTS
3.1 BUREAU VERITAS qualification tests carried out
3.2 Flame resistance test WTD 71 and AEROQUIP's letter BP/Sp dated 03/04/1997
4. APPLICATION / LIMITATION
4.1 May be used for the following services on board:
Sea water and fresh water, fuel oil, hydraulic oil, lube oil, compressed air.
4.2 End fittings as per manufacturer's catalogue. The hoses are to be entirely assembled in the manufacturer's workshop.
4.3 Tapered thread end connections are not to be used for liquid fuel or oil circuits in engine rooms nor any place containing an
ignition source unless otherwise suitably screened at the Society's Surveyor satisfaction.
4.4 The hose assemblies are to be installed according to manufacturer's instructions and BUREAU VERITAS Rules
requirements.
4.5 The hoses are only to be used in short lengths (up to 2 m) and are to be so arranged as to be accessible at all times.
and
5.6 Each Hose with End Fittings is to be hydraulic pressure tested to twice the maximum working pressure under witnessing of a
Society's Surveyor.
6. MARKING OF PRODUCT
Each hose is to be clearly and indelibly marked with at least:
- Manufacturer name or logo
- Type designation
- Date of manufacture
- Nominal Diameter
- Nominal Pressure
- Society's brand as relevant.
7. OTHERS
7.1 This approval is given on the understanding that the Society reserves the right to require check tests to be carried out on the
products at any time and that the Manufacturer will accept full responsibility for informing shipbuilders, ship owners or their
subcontractors of the proper methods of use and general maintenance of the products and the conditions of this approval.
7.2 This certificate supersedes the Type Approval Certificate N 07618/D0 BV issued on 05/11/2013 by the Society.