This document describes two pneumatic compressors used to power equipment in a manufacturing facility. Compressor 01 has a 15HP motor and compresses air up to 12 kgf/cm2, filling a 15m3 receiver tank. Compressor 02 has a larger 20HP motor and compresses air up to the same pressure, filling a smaller 500L receiver tank. Various pieces of equipment like snap shears, looper, pinch rolls, and trail breaker are powered using pneumatic cylinders, valves, and FRL units connected to the compressed air lines from the compressors.
This document describes two pneumatic compressors used to power equipment in a manufacturing facility. Compressor 01 has a 15HP motor and compresses air up to 12 kgf/cm2, filling a 15m3 receiver tank. Compressor 02 has a larger 20HP motor and compresses air up to the same pressure, filling a smaller 500L receiver tank. Various pieces of equipment like snap shears, looper, pinch rolls, and trail breaker are powered using pneumatic cylinders, valves, and FRL units connected to the compressed air lines from the compressors.
This document describes two pneumatic compressors used to power equipment in a manufacturing facility. Compressor 01 has a 15HP motor and compresses air up to 12 kgf/cm2, filling a 15m3 receiver tank. Compressor 02 has a larger 20HP motor and compresses air up to the same pressure, filling a smaller 500L receiver tank. Various pieces of equipment like snap shears, looper, pinch rolls, and trail breaker are powered using pneumatic cylinders, valves, and FRL units connected to the compressed air lines from the compressors.