Professional Documents
Culture Documents
Intstructions Booklet PDF
Intstructions Booklet PDF
5
Building the Remote Materials
Remote
1. Connect battery to battery cable.
Note:
6. Connect the i13 light sensor to the input
labelled 2 on the w22 wireless transmitter. Make sure that the
w22 wireless
light sensor is i13 light sensor (x1)
7. Connect the other output from the w19 split transmitter (x1) Glue dots (x2)
switched to dark
to the other i5 slide dimmer. mode.
4 1
Building the Car
7. Snap the entire circuit onto the
Notes:
mounting board, so that the p1
-Attach all magnetic parts power pack is at the very edge of
together before mounting on the short edge of the mounting
1. Connect battery to battery cable. mounting board, or else the board. Everything should be on
parts will not all stick to the the mounting board.
2. Connect white battery cable to p1 mounting board properly.
power. 8. Connect the wheels to the
-Do not be afraid to to really white cable connected to each o25
push the Little Bits onto the DC motor.
Note: mounting board to get them
to stick properly the Little 9. Place two glue dots and place
Keep p1 power switched off until Bits are sturdy and will not on the black bottom of the ball
ready to test the car, so that car break easily. caster.
wheels will not keep turning and
buzzer will not keep buzzing. 10. Attach ball caster to the
bottom of the mounting board,
underneath the p1 power.
2 3