Professional Documents
Culture Documents
Moai ENSAMBLE - LitArt JPR PDF
Moai ENSAMBLE - LitArt JPR PDF
Watanabe
Parts 1 - 11
4
3
3
2
The surface of part 4 with
the triangle is the front side.
View of completed model
The surface of part 3 with the
*This model was designed for Papercraft and may differ from the original in some respects. red triangle on the glue tabs is the Glue parts 1 - 4 after
front side.Keep these points in mind first gluing parts 5 and 6.
Assembly Instructions:Two US letter sheets(No.1 to No.2) when gluing the parts together.
*Build the model by carefully reading the Assembly Instructions, in the parts sheet page order. 1
Parts 1 - 8 6
7
Assembly Instructions
Glue
Mountain fold(dotted line)
The glue spot(colored dot)
Make a mountain fold.
shows where to apply the glue.
Valley fold(dashed and dotted line) 8
Glue spot(Red dot)
Make a valley fold. Glue parts with the same number together.
9 13
Scissors line(solid line) Glue spot(Green dot)
Cut along the line. Glue within the same part.
Cut in line(solid line) Glue spot(Blue dot)
Cut along the line. Glue to the rear of the other part. 10 14
11
Before gluing, crease the paper along mountain fold and valley 15
Assembly tip fold lines and make sure rounded sections are nice and stiff.
Glue so that the seams
on the rear surface match.
Glue, scissors and other tools may be dangerous to young children
Caution so be sure to keep them out of the reach of young children.
1
Moai statues, Chile: Assembly Instructions Canon is a registered trademark of Canon Inc. Canon Inc. Y.Watanabe
33 34
19 20
29
21 25
Glue the dark-colored
glue tabs to part 23.
30
Parts 16 - 21
29
31
26
30 31
22
27
23
28
24
Glue so that the seams
on the rear surface match. Finished!