Professional Documents
Culture Documents
A10vo GB
A10vo GB
A10vo GB
pump
to the accumulator
August 2003 / sk-gw Page 2 of 19
A10V accumulator charging
pump
Installation instructions
for intake lines on hydraulic pumps, SI 011005
Air
Procedure
Carefully open the accumulator drain cock on the control block
The pressure gauge displays the slow decline of the
accumulator pressure
At a certain point, the pressure suddenly drops to zero.
This point is known as the accumulator pre-charge pressure
The accumulator pre-charge pressure should never be more
than 20 bar below the specified value switchover problems
August 2003 / sk-gw Page 5 of 19
A10V accumulator charging
pump
Setting cylinder
Prerequisite
Fluid at operating temperature (approximately 40 -
50C)
Maximum engine speed
Pressure gauge mounted directly on the FFH control
Pump ON, medium delivery rate
Setting procedure
Set maximum pressure on the pressure limiting valve
directly on the accumulator charging pump in
accordance with the measuring sheet
Always wait for one switchover procedure to check
August 2003 / sk-gw Page 10 of 19
A10V accumulator charging
pump
In-line drive
SAE- A - Fit a gear pump
SAE- B - Fit a second A10VO28
---------- - Cover plate
67,370,003 13 435,845
67,043,000 28 -------
227,880,003 13 -------
202,752,004
+
271,333,001 21
SAE-B 227,880,003 13 SAE-B
403,318 24 403,315
231,665,007 28 -------
261,233,008 13 435,845
289,058,006 16 277,795,009 67,369,001 13
266,655,008 21
-------
202,752,004 + 69,110,009 28
-------
200,600,006 28 -------
222,694,003 13 435,845
245,348,006
271,876,005
21
24
SAE-A
202,752,004
403,315
+ 222,694,003
271,876,005
13
24
SAE-A
259,638,003 28 -------
279,891,008
277,354,000
13
21
SAE-B
-------
202,752,004
+ 279,891,008
246,487,005
13 SAE-B
265,557,000 24
259,640,004 28
SAE-A
------- + 222,694,003 13 SAE-A
246,487,005 13 -------
261,484,009
259,634,007
21
28
SAE-B 202,752,004
-------
+ 246,487,005 13 SAE-B
-------
277,352,002
276,110,009
13
21
-------
202,752,004 + 67,371,002 13 -------