Professional Documents
Culture Documents
Adf PDF
Adf PDF
Use of a single loop aerial suffers from directional ambiguity of 180 0. That is,
null may be to any direction and its opposite. To distinguish this, a sense (omni
directional) aerial
input is combined Aircraft Flying OUT in Direction
with signal of loop of Minimum Signal
aerial and Aircraft Homing in Direction
combined polar of Minimum Signal
(field strength)
diagram is in
shape of cardiod,
with single
minimum. In
modern
equipment effect
of a rotating loop
is created
electronically by 180 AMBIGUITY
two fixed loops placed 900 to each other.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
IDENTIFICATION. Ground stations must be positively identified by their
Morse code. Long range coastal stations use keying break in transmission for this
purpose, while most others are amplitude modulated (AM) transmissions. To hear the
modulated code signal, a Beat Frequency Oscillator (BFO) is used in the airborne
receiver. Position of this facility switch, sometimes referred as Tone is required to be
properly selected on the control unit as under;
BFO Selection
Emission Type
Initial Tuning Code Identification Obtaining Bearing
N0N A1A ON ON OFF
N0N A2A ON OFF OFF
A2A OFF OFF OFF
INDICATORS.
ADF. A fixed card or radio compass indicator always shows relative bearings
which are with fore and aft axis of the helicopter as datum. Therefore, it is called
Relative Bearing Indicator (RBI) also.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
Generally RMI has two pointers, one each for ADF and VOR. If more than
one ADF or VOR receiver is available then any particular combination of the navaids
for indication is possible.
Homing to an NDB while flying in cross wind component condition and trying
to keep ADF reading 000, results in continual change in heading and following a
curved path to station. This is depicted in figure on the left. A better procedure is
tracking to or out of a station. This is achieved by flying a heading with proper
allowance for the drift and following a direct track to the station. Drift correction
depends on wind velocity, TAS and required track of aircraft. This may be calculated
by using navigation computers, or estimated from known information using pilot
navigation thumb rules.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
RMI and ROTATABLE-CARD ADF INDICATOR.
pointer shows the radial (QDR). Its interpretation is quite straight forward, and it is
easy to visualize the relative orientation of helicopter with respect to the NDB.
While flying to keep the helicopter on the radial, trend of ADF pointer is a
useful cue. Simple method is to correct by flying double the error till the track is
regained, and then turn half of the correction in opposite direction. As an example if
RBI is indicating 010 that is position ten degrees to left, alter heading by 20 0 to right.
Once on track indicated now by ADF bearing 340 (R), change heading to left only
by 10, to make allowance for drift of 10 port.
If incorrect drift application has been made you will drift off to one side of the
track. This will result in RBI and bearing to the station not remaining steady. With a
constant heading being
flown divergence from
desired track will be
seen by gradual change
in relative bearing.
Suppose a heading
allowing for 15 S drift is
being flown and the
actual drift is less than
that expected. Helicopter
position will be slowly
moving to the left of the
required track to the
station, and relative
bearing will gradually increase. Appropriate correction either to fly direct to station or
regain track based on distance to go should be carried out.
When uncertain of wind effect, best method is to fly initially track as heading
that is, make no allowance for the drift. After a while, effect of wind will be obvious by
deflection of ADF pointer to left or right. Carry out double the angle correction as
explained above.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
TRACKING OUT FROM STATION. With no cross wind, flying the track as
heading would be fine, and ADF will
remain steady on 1800. In cross wind
conditions allowance for drift is
required. A drift of 50 P and positioned
on desired track the indication would be
175 on the ADF. It is easier to relate to
tail end of pointer which would read
355 and show 5 left, when applied drift
and actual drift are same.
INTERCEPTING A TRACK.
Suppose you are on heading 350 and RMI indicates 070. It is required to intercept
radial 270 (that is 090 track to the NDB). Magnetic bearing to NDB is 070. Imagine
helicopter position pointing in direction of the heading and at tail end of ADF pointer,
and the NDB at centre of the dial. Visualize helicopter along the desired track of 090
to the NDB as shown on grey dotted pointer in the figure. The required track with
respect to present radial is ahead and a turn to the right will be required to reach
station.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
ANGLE TO INTERCEPT. Suitable heading to intercept is based on angle to
intercept the desired track (or radial). While 900 intercept (heading 360 in the
Example above) will
make it earliest to
intercept the required
track, hardly any
distance towards the
station is covered. A
shallower angle say 300
or 450 would close in
faster, both to the track
required and the NDB.
An intercept angle of
double the track
difference for smaller
angles and distances
may be used. Just short
of the required track a
turn equal to the
intercept angle to left or right and allowance for drift would have to be made.
On the right of the figure procedure to track out from on radial 100 when flying
on the radial 070 is shown. Helicopter is flying 065 heading to allow for 5 S drift.
Change in heading to 130 is made to intercept the radial 100 at 30. ADF pointer
reading 185 would read 120 when heading is just changed to 130 from original 065.
Tail end of the pointer will rise from 300 to 330 as required radial is approached. Just
before reaching the radial turn to left is made on heading 095 giving allowance for
expected drift of 5 S.
INTERCEPTING THE RADIAL USING RMI. It is easier to use the RMI for
tracking in or out. The pointer over the moving dial always shows the QDM (magnetic
track to the station). Therefore, information on the current radial is readily available
by reading the tail end of pointer. Figure below displays the same two cases that
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
have been explained above using RBI. On the left in the figure below, a helicopter is
on the 260 radial and is required to intercept and track in on radial 285 (track 105).
With a turn to the left on heading 045 and flying on this heading the QDMs gradually
change from 080 to 105. Just before reaching the track right turn to follow the radial
is initiated.
On the right in the figure case of intercepting a specified radial and tracking out is
shown. Helicopter is to track out on the radial 100 while presently is on 070. A turn on
heading 130 is made to intercept at 30. Radial indication, read off tail of the pointer
change from 070 to 100. Final heading flown is with allowance for the drift as usual.
NIGHT EFFECT. Main path of radio waves from the NDB to the airborne ADF
receiver is known as ground
wave and is along the surface
of the earth. At night
Ionospheric changes take place
and radio waves transmitted
sky wards are refracted back to
earth. The mixing of indirect sky
wave and ground wave causes
distortion of the polar diagram
of loop aerial. As a result ADF
needle wanders and no steady
indications are available. The
effect is most pronounced at
dawn and dusk and long ranges
as ground wave is attenuated.
This effect is also known as Sky
Wave Interference. Protected
ranges published in AIP are not
valid for night. Sometimes day
and night ranges of NDB are
separately given in Aeronautical
publications, latter being less in
range. Increased power of NDB
does not reduce the night effect. Locator beacons with limited coverage are
considered free of this effect.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
COASTAL REFRACTION. Radio waves passing the coastline at small
angles suffer refraction due to different conducting and reflecting properties over land
and sea. A false bearing
indication is obtained at
helicopter flying over sea and
taking bearings from NDB
located over land. The effect is
less for an NDB on coast than
one inland and on a bearing
90 to coastline then at an
oblique angle. Hence, given the
choice use beacon at coast and
rely on bearings perpendicular
to the coastline.
STATIC. Considerable
electrical disturbance is created
by thunderstorms for attenuated
NDB signals at long ranges.
Lightening from the thunderstorms
produces strong signals and
cause the ADF pointer to swing
from direction of NDB towards
electrical storm. Totally incorrect
indications may be obtained
during such adverse weather
conditions.
QUADRANTAL ERROR. NDB signals may reach the receiver aerial directly
and also after being reflected by the
helicopter body. Due to electrical
circuits and current flowing through
them there is an electromagnetic field
surrounding the helicopter, in general
alignment with its body. This causes
the incident radio waves to deflect
near the ADF receiver aerial. The
mixed signal affects the null position
and the bearing indicated may be with
large error. The maximum effect is at
quadrantal relative bearings 045,
135, 225 and 315 relative to heading. Modern installations are compensated for this
error.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
SYNCHRONOUS TRANSMISSION OR STATION INTERFERENCE. If two
NDBs operate at frequencies close
to each other then the bearings
obtained at the ADF would be in
error. This is caused due to mixing
of the radio signals, particularly at
night with long range of undesired
sky waves also being received on
same frequency from a distant
station. In such cases the NDBs
with adjacent or same frequencies
are geographically well separated
in their location.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
SUMMARY
ADF. An airborne LF/MF, receiver operates in conjunction with ground NDB
providing relative bearings.
Principle. Bearing by loop direction finding (DF) or bearing by null method. 180
ambiguity resolved by additional sense antenna. Loops polar diagram of
figure of eight gets modified to cardiod.
BFO. Required for tuning and identification of N0N A1A type and for tuning
only of N0N A2A type NDB transmissions.
Control Unit. Tune on ANT (Sense) and monitor bearings always on ADF
position.
INDICATORS
RBI or ADF. Always indicates relative bearings.
Heading + ADF = Bearing to Station (QDM)
Rotatable Card ADF. Manually setting of heading required for QDM
RMI. Two pointers, selectable to ADF/ VOR, automatic heading input to
rotatable card below. Always display QDM.
Intercepting Track/ Radial. Heading for interception based on final track and
required angle of interception. On interception relative bearing equals the
angle of interception
ERRORS
Night Effect. Sky wave interference due shifting of Ionosphere during night.
Prominent at dawn and dusk and at long ranges. Pointer hunting due
distortion of polar diagram.
Coastal Refraction. Least when bearings normal to coastline.
Static. Electrical disturbance created by thunderstorms for weak NDB signals
at long ranges cause the ADF pointer to swing towards electrical storm.
Quadrantal Error. Maximum at relative quadrantal bearings to heading.
Terrain and Mountain Effect. Reflection and diffraction causes fluctuations
in signal. Error or sudden change in bearings. Higher frequency reduces
the problem.
Synchronous Transmission. Maximum at relative quadrantal bearings to
heading due intervening effect of electro-magnetic field around airplane.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
SAMPLE QUESTIONS: ADF/ NDB
(a) VLF or LF
(b) VHF or HF
(c) LF or MF
(d) MF or HF
2. Greatest range from an NDB considering other factors equal, will be obtained
with following radio transmission and emission:
3. An NDB emits N0N A2A signal. Pilot should select BFO switch to on position
5. The ADF indication is 335 while helicopter is on heading 225 (M). Magnetic
bearing to the NDB is
(a) 020.
(b) 225.
(c) 200.
(d) 045.
(a) 045.
(b) 030.
(c) 360.
(d) 350.
7. Flying over sea and options available, to obtain accurate ADF bearing the
pilot should fly at
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
8. Protected range of an NDB is valid
(a) 045.
(b) 070.
(c) 090.
(d) 295.
11. Helicopter is flying heading of 285 (M) and is on the radial of 095. ADF
indication will be
(a) 170
(b) 010
(c) 190
(d) 350
12. Greatest range during day, all other factors being equal, will be obtained from
an NDB operating on frequency of
13. Helicopter flying on heading 040 (M), the pilot observes ADF 015 (R). To
intercept the radial 260 at 30 and to track in on the radial pilot should turn on
heading
(a) 050.
(b) 230.
(c) 290.
(d) 110.
14. While RMI indicates 270 for NDB, pilot to track out on radial 100 should turn
on heading
(a) 310
(b) 070
(c) 250
(d) 130
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
15. Helicopter is keeping heading 340 (M) to intercept the required radial at 60
angle and is tracking to station. On approaching the required radial RMI will
read
(a) 040.
(b) 220.
(c) 280.
(d) 340.
16. As a general rule sky wave or night effect will cause maximum error in
bearings obtained from
(a) an NDB provided as a terminal aid.
(b) a locator beacon associated with ILS marker.
(c) long range NDB for air route navigation at long distance.
(d) all categories of NDB equally.
19. Helicopter is flying 225 (M) to track out on radial 225 and finds ADF reading to
be 170. To intercept the radial, the pilot should turn
(a) right on heading 245.
(b) left on heading 215.
(c) right on heading 235.
(d) left on heading 205.
20. Heading 260 (M) is being flown to intercept the required radial at 30 and then
fly to the NDB. Nearing the radial will be indicated when ADF reads
(a) 290.
(b) 330.
(c) 150.
(d) 210.
21. A factor that does not directly affect the reception range of NDB out of the
following is:
(a) Night Effect
(b) Frequency of transmitter
(c) Static Interference
(d) Power of transmitter
22. The factor that directly affects the accuracy of ADF bearing at a given range
amongst the following is:
(a) Power of transmitter
(b) Frequency of NDB
(c) Quadrantal Error
(d) Coastal refraction.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
23. Ambiguity of 180 is resolved by;
(a) an additional sensing aerial
(b) rotating the loop through 90
(c) using a rotating card indicator like RMI
(d) pilot setting the heading and rotating the card manually.
24. In case of use of ADF/ NDB, the control knob for obtaining the bearing must
be selected at;
(a) BFO position
(b) REC position
(c) TST position
(d) ADF position
25. The control knob in case of use of ADF/ NDB, for tuning the station must be
selected at..position.
(a) ADF
(b) REC
(c) TST
(d) BFO
28. Helicopter pilot flying over sea can reduce the effect of coastal refraction by
flying
(a) low and using bearings from station located well inland
(b) high and using bearings from station located well inland
(c) low and using bearings from station located at coast
(d) high and using bearings from station located at coast.
30. To obtain magnetic track to fly away from the station, magnetic heading
should be indicated relative ADF bearing.
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com
ANSWERS: ADF / NDB
1 c 21 c
2 b 22 c
3 a 23 a
4 d 24 d
5 c 25 b
6 a 26 a
7 d 27 b
8 b 28 d
9 b 29 c
10 c 30 d
11 d
12 c
13 a
14 d
15 a
16 c
17 b
18 d
19 a
20 b
The Rotary Wing Society of India Notes by: Gp Capt SK Manocha (Retd) skmanocha@rediffmail.com