Professional Documents
Culture Documents
(PDS) Lokfix Ep
(PDS) Lokfix Ep
Lokfix EP
Feb 07
constructive solutions
(Formerly known as Expogrout Putty)
Uses Colour
Part ‘A’ base (white)
Lokfix EP is general purpose epoxy putty recommended
for the following typical applications Part ‘B’ curing agent (black)
Description 1 day 75 75 75 30
Lokfix EP is supplied in the correct proportions for mixing. Gel Time 1 hour at 25 degrees centigrade
Page 1
Lokfix EP
(Formerly known as Expogrout Putty)
Cleaning
Application Instructions
Use Fosorc Equipment cleaner to clean equipement
Surface preparation
immediately after use. Hardened material can only be
Surface to be free from oil, grease; laitance and loose removed mechanically.
material. Remove fine dust from substrate; as well as any
Precautions
free standing water.
Health & Safety
Application
Lokfix EP
Apply the mixed product using suitable spatulas or trowels.
Contains epoxy resin which may cause skin sensitisation in
Mixing
certain conditions. Skin contact should be avoided and a
Mix Part A and Part B thoroughly using a spatula. Uniform suitable barrier cream applied or disposable rubber or
mixing is indicated when the black and white colour of the plastic gloves worn. Hands should be thoroughly washed
components merge to form a uniform grey colour free of before eating or smoking. Anyone having open wounds, or
streaks. Mixing of part packs is possible only if the cuts on hands or forearms, however small, is advised to
recommended rations are strictly adhered to. Deviations avoid contact with epoxy resins until the skin is healed.
from this will result in material which will not achieve the
Fosroc Joint Cleaner
desired properties.
Flammable liquid, Flash point 35oC. Store away from heat.
1. Under water application
Do not use near naked flame. Use in well ventilated
Product must be mixed on surface. Protect from water surroundings. Avoid skin contact and inhalation of the
during transfer from surface to point of application. vapour.
A notched trowel must be used to spread the compound. Fosroc Joint Cleaner
For mixing larger quantity, the mixing temperature must be degreasing. Plastic and plastic surfaces should be tested
kept at 20 – 25 degrees centigrade otherwise pot life will be first before general application.
Important note
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions for the
Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that any advice,
recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct or continuous control
over where or how its products are applied, accept any liability either directly or indirectly arising from the use of its products, whether or
not in accordance with any advice, specification, recommendation of information given by it.
Fosroc Singapore
30 Toh Guan Road telephone: fax: email:
#07-07, ODC Districentre + 65 6665 3828 + 65 6899 1283 Fosroc.Singapore@Fosroc.com
Singapore 608840
www.fosroc.com
Page 2