Professional Documents
Culture Documents
RAB EstFailPs Cell PDF
RAB EstFailPs Cell PDF
Cell) Page 1 of 4
The CN in PS domain initiates the radio access bearer setup procedure by sending a RAB ASSIGNMENT
REQUEST message to the RNC.
After receiving the RAB ASSIGNMENT REQUEST message, the RNC selects an appropriate cell, allocates
resources, and performs admission control based on the information in the message (such as service type,
QoS, and priority), the traffic load of the system, and the networking strategy (such as DRD). The
requirements of high-priority users are met preferentially(That is, when the resources are insufficient and
the UEs with low-priority cannot set up the RAB, the RNC sends to the CN a RAB ASSGNMENT
RESPONSE message if the queuing algorithm is enabled, indicating that the RAB is in the queue to wait for
resources). If the admission of the RAB succeeds, the RNC starts the Iu transport connection setup
procedure, the Iub radio bearer setup procedure, and the Uu radio bearer setup procedure. At last, the RNC
sends to the CN a RAB ASSNMENT RESPONSE, indicating whether the RAB setup is successful.
If DRD is enabled during the RAB setup, the RAB setup measurement is performed on the DRD target cell.
Otherwise, the RAB setup measurement is performed on the DRD source cell.
The RAB setup procedure is as follows.
Figure 1 RAB Setup Flow
mk:@MSITStore:C:\Solutions\VendorDocumentation\UTRAN\Huawei\R12\BSC690... 24/07/2013
Measurement of PS RAB assignment failure per cell(RAB.EstFailPs.Cell) Page 2 of 4
mk:@MSITStore:C:\Solutions\VendorDocumentation\UTRAN\Huawei\R12\BSC690... 24/07/2013
Measurement of PS RAB assignment failure per cell(RAB.EstFailPs.Cell) Page 3 of 4
Measurement Counters
mk:@MSITStore:C:\Solutions\VendorDocumentation\UTRAN\Huawei\R12\BSC690... 24/07/2013
Measurement of PS RAB assignment failure per cell(RAB.EstFailPs.Cell) Page 4 of 4
Counter Relationship
mk:@MSITStore:C:\Solutions\VendorDocumentation\UTRAN\Huawei\R12\BSC690... 24/07/2013