Download as pdf
Download as pdf
You are on page 1of 1
subject to the seismic requirements of Section 1,174.3 of TMS 402/ACI S30/ASCE 5. 3, Seismic Design Category D. A design using Tables 1807.1.6.3(2) through 1807.1.6.3¢4) is subject to the seismic requirements of Section 1.17.44 of TMS 402/ACI S30/ASCE 5, 4, Seismic Design Categories B and F. A design using Tables 1807.1.6.3(2) through 1807.1.6.3(4) is subject to the seismic require- ments of Section 1.17.45 of TMS 402/ACT S30/ASCE 5. 1807.2 Retaining walls. Retaining walls shall be designed in accordance with Sections 1807.2.1 through 1807.2.3. 1807.21 General. Retaining walls shall be designed to censure stability agains| overturning, siding, excessive foun- ‘SOILS AND FOUNDATIONS dation pressure and water uplift. Where a keyway is extended below the wall base withthe intent to engage pas- sive pressure and enhance sliding stability, lateral soil pres- sures on both sides of the keyway shall be considered in the sliding analysis 1807.2.2 Design lateral soil loads. Retaining walls shall be designed forthe lateral sil loads set forthin Section 1610, The load combinations of Section 1605 shall not apply to this requirement. Instead, design shall be based on 0.7 times nominal earthquake loads, 1.0 times other nominal loads, and investigation with one or mote of the variable loads set to zero. The safety factor against lateral sliding shall be taken a the available soil resistance al the base ofthe retain- TABLE 1807-1.6.3(4) {12:INCH MASONRY FOUNDATION WALLS WITH REINFORCEMENT WHERE d > 6.75 INCHES**« MINIMUM VERTICAL REINFORCEMENT-BAR SIZE AND SPACING inches) maxmum wane weranr | ““Baexmut cian Deston tera oi end” (pt per fotet dept) (letinehes}. (letinehes) ao * © maT wea 72 iat72 +4 wad as at 72 asa 72 Hat aT asa 72 a4at72 a5 72 aoa 72 4 (ess) aan are war 50 maT? maT weaT2 80 69 maT a7? 572 19 ward a5 at72 oat 72 “0 sat 6 at 7 sat 72 4 (or less) a4ac72 waa72 waat72 50 wad asat72 sat 72 88 0 maid aT 5 at 72 10 maT asa72 woa72 ss ead aratT 8a 72 4 (or less) maT? ware weat72 50 Bard a7 a7? oa 60 ead sat 72 #50072 10 Mad sat 72 Wat 72 80 #atT wea72 nan ona 45.072 ana 72 eat 72 4 (or less) maT wat 72 wat T2 50 maT iaa72 a7? 0 wat72 a5 at 72 45387 100 10 Marr neat 72 Neat 72 30 asa72 wea72 aT 9-0" 45.8072 aya 72 sat 72 10-0" man eat 72 n9at72 For Sk iach =25 mm, 1 foot = 3048 mm, a Fer design lateral sol loud, se Seton 1610 & «For alleratve reinforcement, se Section 1807.16. 4 For height of unbalanced bckfl, ee Section 1807 1.2. rol apphicale See Secon 1610, 2009 INTERNATIONAL BUILDING CODE® 1 pound per squats fot pe foot = 0.157 KPa, Provisions fr tis table are based on design and contruction requirements specid in Section 1807.1.63. ‘Where nbslanced backs eight exesede 8 fer and design nea sollonds fom Table 1610.1 ae ued the sequrement for 30 an 5 pa per oot of doth ace 37

You might also like