Professional Documents
Culture Documents
Autonomous Level Control Bench (RCN 200)
Autonomous Level Control Bench (RCN 200)
EDUCATIONAL APPLICATIONS
-Study of a level control loop
-Identification of the elements: sensors,
controller, actuator, disruptive
-Configuration of the interface controller
-Regulation PID or Adaptive auto
-Visualization of different signals by software
-Characteristic curves (level, opening valve)
APLIKASI PENDIDIKAN
-Studi dari tingkat kontrol loop
-Identifikasi elemen: sensor, controller, aktuator,
mengganggu
-Konfigurasi controller interface
-Auto peraturan PID atau adaptif
-Visualisasi dari sinyal yang berbeda oleh
perangkat lunak
Autonomous Level Control Bench (RCN 200) -Karakteristik kurva (tingkat, membuka katup)
PRINCIPLE OF OPERATION
The NCR 200 bench allows the study of the level control. A pump ensures the water supply in a
transparent test tank. A capacitive sensor measures the water level in the tank. A digital PID
controller receives information from level and should adjust the speed of the pump driven by the
drive to reach the set point.
The unit is supplied complete, instrumented with technical and pedagogical documentation in
french as well as all accessories necessary for the proper functioning (included the supervision
software)
The robust design of this equipment makes it perfectly suitable for use in schools.
Its structure in aluminium anodised on wheels gives it a very high robustness and flexibility of
integration in your premises. Manufacturing of this equipment complies with the European
machine directive.
Note: For installation of equipment by our services, all connections to networks must be less than
2 m from the machine
Operating Instructions
Teaching manual on regulating technical Dossier
Work practices
Technical documentation of all PC components for the supervision not included
Certificate of conformity
Setting Curve Supervision
The bench is also equipped with origin of supervision and parameterization software. The
connection to the PC is done by a standard USB port. The software is divided into three parts:
SETTING
This part provides access to the settings of the display directly via a similar to that of Windows
Explorer of data.
The front controller is reproduced on the screen of the PC and the operator can operate the
buttons and controls as
If he was on the driver.
TRACE CURVES
This section allows to draw curves with the controller signals.
For example on this image below display the setpoint and measurement in real time, but it is
possible to add other parameters like output signal...
The data stored in the trace can then be saved to a file in Excel format.
SUPERVISION
This part is used to configure the controller in a simple way and visualize the evolution of the
parameters. A window is attributed to each loop.
Each window is arranged as shown in the images above - against:
-a diagram takes the circuit used
-a table contains the settings (measure, set parameters PID, signal output...)