Professional Documents
Culture Documents
CURICULUM VITAE (Batam)
CURICULUM VITAE (Batam)
PERSONAL DATA
Education
- Politeknik Caltex Riau, ( Diploma Degree)
Mechatronic Engineering (graduated in 2013 with GPA 2.45)
Qualification
- Welding Inspector BNSP (National Profesional Certification) Cert No :
0011131170022782016
- Radiographic Interpretation ASNT Level II
Summary of Experience
o More than 1 year experience as Welding Inspector in Marine & Shipbuilding, Fabrication
of module in Oil & Gas industry.
o Familiar with Inspection activities, Welding Process, Piping Test Pack, Hydro test,
P&ID/ ISO drawing, Code and Client Spec.
o Familiar with code: API 1104, API 650 & 653, ASME IX, ASME B31.3, ASME B31.8
And AWS D1.1
PROFESSIONAL EXPERIENCE
October 2017 – March 2017
QC inspector PT. NOV (Profab)
- Project: KAOMBO
Job Responsibilities:
- Check and Inspect during joint preparation/Fit-Up accordance to WPS and Related
Procedure include ( Type, Heat No. dimension, orientation) Witness, control and record the
parameters for each weld performed (preheat if any, electrode storage and etc.).
- Check Dimension before and after welding using Dumpy level (Sokkia)
- Monitoring welding process as required by procedure
- Conduct visual inspection before NDT
- Final Inspection before release to Painting ( Check Dimensions , Distortion & Tolerance as
per code or client Spec
- Witness with client Hydro test activity, Leak test activity, verify certification and
calibration of equipment, hydro jetting before test run.
- Line check after pipe install into pipe rack following isometric drawing and P&ID drawing
(Monitor cutting material in order to ensure conform with drawing, specification)
Job Responsibilities:
- Prepare WPS document, Material certificate, ITP,
- Check and Inspect during joint preparation/Fit-Up accordance to WPS and Related
Procedure include ( Type, Heat No. dimension, orientation) Witness, control and record the
parameters for each weld performed (preheat if any, electrode storage and etc.).
- Monitoring welding process as required by procedure
- Conduct visual inspection before NDT
- Final Inspection before release to Painting & Galvanization ( Check Dimensions , Distortion
& Tolerance as per code or client Spec
- Witness with client Hydro test activity, verify certification and calibration of equipment,
flushing and hydro jetting before test run.
- Line check after pipe install into pipe rack following isometric drawing and P&ID drawing
(Monitor cutting material in order to ensure conform with drawing, specification)
- Make document report for MDR, Welding Traceability Record, Material Traceability
Records, Visual Report, Material Map, Dimensional Reports, Etc.
Personal References:
- Prima refli, Method Engineer Saipem Indonesia, primarenaery.refli@saipem.com
-