1. LED 4 indicates a failure of the servovalve current or solenoid valve for the spoiler block valves in zones C1 and C2.
2. The maintenance note specifies that the fault should not be reset before switching off the EFCU so the fault code is stored in memory. Both EFCU positions and codes should be recorded.
3. LED 5 indicates a failure of the transducer for roll control or speedbrake.
1. LED 4 indicates a failure of the servovalve current or solenoid valve for the spoiler block valves in zones C1 and C2.
2. The maintenance note specifies that the fault should not be reset before switching off the EFCU so the fault code is stored in memory. Both EFCU positions and codes should be recorded.
3. LED 5 indicates a failure of the transducer for roll control or speedbrake.
1. LED 4 indicates a failure of the servovalve current or solenoid valve for the spoiler block valves in zones C1 and C2.
2. The maintenance note specifies that the fault should not be reset before switching off the EFCU so the fault code is stored in memory. Both EFCU positions and codes should be recorded.
3. LED 5 indicates a failure of the transducer for roll control or speedbrake.
LED 4 in C1 or C2 : Failure of servovalve (SV) current or Maintenance Note :
solenoid (S) valve continuity. To facilitate subsequent trouble shooting at workshop level, ensure that the bite is not reset before the EFCU has been switched off because the FIN Functional designation Panel Zone Access Door EFCU 1 - BITE DISPLAY light is ON - Spoiler FAULT legends are ON BITE code is stored in memory only after switching-off the EFCU. Record 7CS Transducer Unit - Spd Brk Ctl 121 121BL LED ON Spoiler Block Valve Affected TSM ref. also both EFCU positions and their codes. 8CS M/Switch-Throttle Lever Engine 2 112VU 121 121BL C1 C2 9CS M/Switch-Throttle Lever Engine 1 113VU 121 121BL 4 6L 2L 27-61-04 Fig. 101 FIN Functional designation Panel Zone Access Door 4-8 SV 6R 2R 27-61-04 Fig. 101 10CS Actuator-Splr 2, R 672 4-7 7L 3L 27-61-04 Fig. 101 1CP EFCU-1 92VU 122 121BL 11CS Actuator-Splr 2, L 572 4-7-8 4-6-7 4-6-7-8 S 7R - - 3R 2L 2R 27-61-04 Fig. 101 27-61-04 Fig. 102 27-61-04 Fig. 102 2CP 3CP EFCU-1 Transducer Unit - Roll Ctl. Capt. 93VU 122 121 121BL 121BL 12CS 13CS Actuator-Splr 1, R Actuator-Splr 1, L 672 572 A310 17CP P/BSW-Splr & Spd Brk, 3 & 2 428VU 211 14CS Valve Group-Splr 1, R 672 SPOILER CONTROL COMPUTERS 18CP P/BSW-Splr & Spd Brk, 6 428VU 211 15CS Valve Group-Splr 1, L 572 TROUBLE SHOOTING GUIDELINES EFCU 2 - BITE DISPLAY light is ON - Spoiler FAULT legends are ON 20CP P/BSW-Splr & Spd Brk, 7 428VU 211 16CS Valve Group-Splr 2, R 672 LED ON Spoiler Block Valve Affected TSM ref. 22CP Actuator-Splr 3, R 681 17CS Valve Group-Splr 2, L 572 2 1 1 2 C1 C2 23CP Actuator-Splr 3, L 581 3 3 41CS MSW-Gnd Splrs P/select Lane 1 9VU 210 4 B Y Y B 4 4 - 1L 27-61-04 Fig. 101 24CP Actuator-Splr 6, R 681 B B 5 - 1R 43CS Relay-Gnd Splrs Fault Sel Lane 2 122 121BL 5 Y 4-8 SV 27-61-04 Fig. 101 6 Y 6 4-7 5L 4L 27-61-04 Fig. 101 25CP Actuator-Splr 6, L 581 7 G G 7 44CS Relay-Gnd Splrs Fault Sel Lane 2 122 121BL Y Y 4-7-8 5R 4R 27-61-04 Fig. 101 26CP Actuator-Splr 7, R 681 B B 4-6-7 - 1L 27-61-04 Fig. 102 47CS Annunciator-G/S Sel Lane Fault 471VU 212 A A 4-6-7-8 S - 1R 27-61-04 Fig. 102 27CP Actuator-Splr 7, L 581 51CS M/Switch-Throttle Lever Engine 2 113VU 121 121BL 30CP Valve Group-Splr 3, R 681 52CS M/Switch-Throttle Lever Engine 1 112VU 121 121BL C D B B D C 31CP Valve Group-Splr 3, L 581 32CP Valve Group-Splr 6, R 681 LED 5 : Failure of transducer (roll control or speedbrake) *Applies only to spoilers post AI SB 27-2012 33CP Valve Group-Splr 6, L 581 SPLR & SPD BRK 428 7 6 5 4&1 3&2 VU 34CP Valve Group-Splr 7, R 681 EFCU 1 - BITE DISPLAY light is ON - Spoiler FAULT legends are ON FAULT FAULT FAULT FAULT FAULT LED ON Transducer or 26VAC Power TSM ref. 35CP Valve Group-Splr 7, L 581 OFF OFF OFF OFF OFF
5 Rud Trim 6L 2L 1L 27-61-05 Fig. 101 42CP Relay-Solid State 93VU 122 121BL Note : The recommendations included do not amend or 5-8 - 6R 2R 1R Rud Trim Ref. 5-7 5L 7L 3L 4L 27-21-00 56CP P/BSW-Splr & Spd Brk, 1 & 4 428VU 211 supersede any information contained in the Airbus EFCU 1CP EFCU 2CP 5-7-8 5R 7R 3R 4R 58CP P/BSW-Splr & Spd Brk, 5 428VU 211 Industrie manuals. Ground 60CP Actuator-Splr 4, R 681 Monitor Control Control Monitor Spoiler Monitor Control Control Monitor Roll Ctl T.U. Unit D Unit C Unit A Unit B Input Unit C Unit D Unit B Unit A 5-6-7 F/O Capt Capt F/O 27-61-05 Fig. 101 61CP Actuator-Splr 4, L 581 M1 C1 C2 M2 M1 C1 C2 M2 681 Note : This document will not be updated on a regular basis 62CP Actuator-Splr 5, R 5-6-7-8 Spd Brk T.U. 27-61-06 Fig. 101 63CP Actuator-Splr 5, L 581 66CP Valve Group-Splr 4, R 681 EFCU 2 - BITE DISPLAY light is ON - Spoiler FAULT legends are ON 67CP Valve Group-Splr 4, L 581 To Control and Monitor units LED ON Transducer or 26VAC Power TSM ref. 68CP Valve Group-Splr 5, R 681 Cpt’s Roll Speed brake F/O’s Roll Control control unit & Control M1 C1 C2 M2 69CP Valve Group-Splr 5, L 581 Transducers ground spoiler Transducers 5 6L Rud Trim 1L 2L 27-61-05 Fig. 101 74CP Transducer Unit-Roll Ctl, F/O 122 121BL preselection 5-8 6R - 1R 2R Rud Trim Ref. 5-7 7L 5L 4L 3L 27-21-00 3CS Switch-Flight Controls Test Selector 471VU 212 5-7-8 7R 5R 4R 3R 4CS MSW-Gnd Splrs P/select Lane 2 9VU 210 Roll Ctl T.U. 5CS P/BSW-PTT 471VU 121 5-6-7 Capt F/Ot F/O Capt 27-61-05 Fig. 101