Professional Documents
Culture Documents
ECM (Hydrostatic Transmission)
ECM (Hydrostatic Transmission)
Operación de Sistemas
D3G, D4G and D5G HYSTAT Track-Type Tractors Electrohydraulic Power Train Systems
Número de medio -RENR7314-00 Fecha de publicación -01/10/2003 Fecha de actualización -30/10/2003
i01999852
Ver imagen
Illustration 1 g00785019
Electronic Control Module (ECM)
The hydrostatic transmission electronic control module (ECM) makes decisions that are based on input
information and memory information. After the hydrostatic transmission ECM receives the input
information, the hydrostatic transmission ECM sends a corresponding response to the outputs. The
inputs and outputs of the hydrostatic transmission ECM are connected to the machine harness by two 70
contact connectors (J1 and J2). The access door for the ECM is located on the left side of the machine
below the cab. The ECM sends the information to the Caterpillar Electronic Technician on the CAT data
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2011
Service Information System Page 2 of 5
link.
Note: The ECM is not serviceable. The ECM must be replaced if the ECM is damaged. Replace the
ECM if a failure is diagnosed.
Inputs
The inputs describe the status of the machine systems. Two types of inputs exist. The inputs can be
either a switch type or a sensor type. Switches provide an open, a ground, or a + battery signal to the
inputs of the controller. Sensors (frequency, PWM or voltage) provide a changing signal to the sensor
inputs of the controller. The inputs to the hydrostatic transmission ECM are listed in table 1 and table 2.
Outputs
The hydrostatic transmission ECM responds to decisions by sending electrical signals to the outputs.
The outputs can create an action or the outputs can provide information to the operator or the service
technician. The outputs of the hydrostatic transmission ECM are listed in table 1 and table 2.
Input/Output
The CAT data link is used in order to provide a connection for the service tool for troubleshooting,
testing, and calibrations. The data link is bidirectional. The data link allows the ECM to receive
information. The data link allows the ECM to send information.
Table 1
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2011
Service Information System Page 3 of 5
Table 2
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2011
Service Information System Page 4 of 5
59
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2011
Service Information System Page 5 of 5
Copyright 1993 - 2011 Caterpillar Inc. Wed Jan 26 12:39:40 CST 2011
Todos los derechos reservados.
Red privada para licenciados del SIS.
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2011