10 cm from the cover rotating part to be brazed. the cable with Use the most specific care not adapted cutter for to damage the operation. copper wires.
Remove the Check radius
plastic cover from compatibility the cable over 3 between cable cm. and connector.
Insert the Make sure
connector on the connector fits in copper cable and covers the turning slightly to full copper till ease the the plastic edge. placement.
Place the Melt slowly the
connector in a tin till connector vise and heat it is filled.. with a blowlamp equipped with a half round pipe.
BRAZING CONNECTORS PROCEDURE VERSION 1
JULY 7th 2009 Siret 483 196 093 000 15 – SARL au capital de 7500 € - n° TVA intra com FR 80 421 347 006 Keep on heating Tinning: move and insert slowly up and down the cable in the slowly to connector full of make the tin tin. Avoid spilling spreading all the tin out of the over the cable. connector.
Once the cable Fill again the
tinned, brazing can connector with be done. tin.
Insert, while Cool down in
heating, the tinned a water bucket. cable in the Check that connector. connector is fixed to the cable without gap!
Prepare a 5 cm Cover both the
long shrinkable connector and tube with the the cable. appropriate radius.
The tube shall not Prepare the
cover the shrinkable connecting part to tube heater. preserve electric contact.
BRAZING CONNECTORS PROCEDURE version 1
Page 2 Apply appropriate Check the tube heating while is covering all rotating the cable the requested till the tube shrinks area. Brazing properly. is completed.