Professional Documents
Culture Documents
Safety
Safety
222) The maximum capacity of an Oil fuel tank for any ship built on or after 1st Aug. 2010 as
restricted by Marpol, Annex 1 is:
A. 600 m3
B. 1200 m3
C. 2500 m3(correct)
D. 3000 m3
Answer-C
223) What is added to Co2 cylinder to avoid from freezing at subzero temp in an inflatable
liferaft?
1)nitrogen(correct)
2)Silica Gel
3)Hydrogen
4)none of the above
Answer-A
224). Under ISM code ,who on board is responsible for reviewing and suggesting changes to
SMS:
a. Chief Engg.
b.Chief Mate
c.Master
d. Designated Safety Officer(correct)
Answer-D
225) Subsequent to a oil spill in Engine Room and ingress of oil in the bilge wells ,the best course
of action is to _______________________________
A.Use oil spill dispersant chemical in the bilge wells
B.Transfer the oily mixture and let it settle in the bilge holding tank/bilge separator tank..
C.Transfer the oily mixture using a portable pneumatic pump to a waste oil tank and then
physically demuck and clean the bilge wells using environment friendly cleaner(correct)
D.Dilute the bilge wells by flooding with water and then use the general service pump to pump
out the bilges
Answer-C
226) Safety standards and guidelines for helicopter operations and rescue can be found in the:
A. Training manual
B. Safety manual
C. International Civil Aviation Organization (ICAO) publication
D. International standards of maritime search and rescue(correct)
Answer-D
228) Freight paid by charterers on a quantity of cargo short-shipped, i.e quantity agreed upon but
not loaded by the charterer, is called:
A. Pro-rata freight Pro rata freight is an ancient form of settling payment for carriage of goods by
sea when ship was not able to reach her final destination,
B. Back Freight A payment that is owed to a maritime shipping company when the transportation
of goods extends beyond the contracted destination ...
C. Dead freight Charge payable on space booked on a ship but not utilized by the charterer or the
shipper(correct)
D. None of the above
Answer-C
29) Post Nox emission test bed trial and approval of an engine, periodic Nox emission limit
verification is normally done by:
A. Emission tests at regular intervals
B. Engine parameters/settings check metho
C. By running the engine at full load and sending a sample of exhaust gas for analysis
D. By checking emission monitors installed on exhaust outlet
Answer-B
231) An airplane wants a vessel to change course and proceed towards a vessel in distress. The
actions of the aircraft to convey this message will NOT include __________.
a. circling the vessel at least once
b. heading in the direction of the distress location
c. flashing the navigation lights on and off(correct)
d. crossing ahead and rocking the wings
Answer-C
234) Records of tests and inspections of a cargo vessel's fire extinguishing systems shall be kept
on board __________.
a. for 1 year
b. for 2 years
c. until the next Coast Guard inspection
d. until the vessel's Certificate of Inspection expires(correct)
Answer-D
235)..by using which of the tank we can change the draft but not changing trim of the ship
a]peak tank,
b]DB tank,
c) deep tank,(correct)
d) top side tk
Answer-C
NOT SURE
NEXT
239).Panting frames are located in the __________.
A) after double bottoms
B) centerline tanks on tankships
C) fore and after peaks(correct)
D) forward double bottoms
Answer-C
241)The difference between the starboard and port drafts due to wind or seas is called
__________.
A) list
B)heel(correct)
C) trim
D) flotation
Answer-B
238).What is normally used to pass a mooring line to a dock?
A Distance line
B Gantline
C Heaving line(correct)
D Tag line
Answer-C
242)Which of the devices listed must be used in conjunction with the portable in-line foam
proportioner to produce foam?
A. A plain or common fire hose nozzle
B. The mechanical foam nozzle(correct)
C. Any low velocity applicator
D. An all-purpose nozzle
Answer-B
243)Minimum possible no. of watertight bulkheads in ships with machinery space amidships is
a) 4(correct)
b) 3
c) 2
d) 5
Answer-A
187) Which of the following codes is mandatory for chemical tankers constructed on or after
1July2010
A. IGC code
B. BCH code
C. IBC code
D. IMDG code
Answer-NOT SURE
191) .What is the minimum percentage of oxygen required before making an entry into an
enclosed space?
A. 20%
B. 18%
C. 11%
D. 21%(correct)
Answer-D
193)Selective catalytic reduction is a secondary method for reduction of which of the following
emissions?
A. SOX
B. NOX(correct)
C. Carbon oxides
D. All of the above
Answer-B
197) A representative sample of fuel oil delivered on board during bunkering is to be retained on
board ________________________
A. For a period of 6 months
B. Till the time the oil is substantially consumed
C. For a period of 12 months
D. Till the time the oil is substantially consumed but not less than 12 months(correct)
Answer-D
Q- Your vessel has a displacement of 19,800 tons. It is 464 feet long, and has a beam of 64 feet.
You have timed its full rolling period to be 21.0 seconds. What is your vessel's approximate GM?
a. 1.1 ft
b. 1.3 ft
c. 1.6 ft
d. 1.8 ft
Answer-D
Q- During cargo operations, your vessel develops a list due to the center of gravity rising above
the transverse metacenter. To correct the list, you should __________.
a. shift weight to the high side
b. shift weight to the centerline
c. add weight in the lower holds or double bottoms
d. remove weight from the lower holds or double bottoms
Answer-C
Q- When should you first have any food or water after boarding a lifeboat or liferaft?
a. After 12 hours
b. After 24 hours
c. Within 48 hours
d. Some food and water should be consumed immediately and then not until 48 hours later
Answer-B
Q- Which statement concerning carbon dioxide is FALSE?
a. It displaces the oxygen in the air.
b. It cannot be seen.
c. It cannot be smelled.
d. It is safe to use near personnel in a confined space.
Answer-D