Professional Documents
Culture Documents
Removing and Installing Selector Lever Lock Solenoid - N110 and Wiring For Selector Lever Illumin
Removing and Installing Selector Lever Lock Solenoid - N110 and Wiring For Selector Lever Illumin
=> General body repairs, Interior; Repair group 68; Trays, compartments and trim
‒ → Disconnect connector -1- (console
wiring).
‒ Using a screwdriver, press in metal
tab on underside of solenoid -2- and
at same time turn solenoid about 90°
in direction of arrow. Take out
solenoid.
‒ Check selector mechanism after
replacing solenoid=>Page 37-16.
‒ Route cable for selector lever
illumination under guide -3- and fix
into notch -4- (left/right).
‒ Clip connector -5- into retainer on
guide.
‒ Reconnect connector -1- (wiring
console).
Create PDF files without this message by purchasing novaPDF printer (http://www.novapdf.com)
vw-wi://rl/A.en-GB.8D-A-A01N.wi::20845009.xml?xsl=2 18.07.2012