The document describes procedures for two tasks involving drawing sketches in CAD software. For both tasks, the procedures involve drawing a base line, additional lines of random dimensions, using the equal command to make lines the same length, drawing a central part using horizontal and vertical relationships, drawing matching lines and curves using the equal command, drawing circles at given points, adjusting dimensions using the dimension command, and using the protrusion command to complete the sketch.
The document describes procedures for two tasks involving drawing sketches in CAD software. For both tasks, the procedures involve drawing a base line, additional lines of random dimensions, using the equal command to make lines the same length, drawing a central part using horizontal and vertical relationships, drawing matching lines and curves using the equal command, drawing circles at given points, adjusting dimensions using the dimension command, and using the protrusion command to complete the sketch.
The document describes procedures for two tasks involving drawing sketches in CAD software. For both tasks, the procedures involve drawing a base line, additional lines of random dimensions, using the equal command to make lines the same length, drawing a central part using horizontal and vertical relationships, drawing matching lines and curves using the equal command, drawing circles at given points, adjusting dimensions using the dimension command, and using the protrusion command to complete the sketch.
2. Draw lines of random dimensions. 3. Use equal command for same length lines. 4. Using horizontal/vertical commands relationship to make central part. 5. Similarly draw lines and curves and use equal command to equal them. 6. Draw circles at the given point. 7. Use dimension command to adjust the dimensions of different lines and curves. 8. Use protrusion command to draw the sketch. TASK NO 2
Procedure2:
1. Draw a base line of given length.
2. Draw lines of random dimensions. 3. Use equal command for same length lines 4. Using horizontal/vertical commands relationship to make central part. 5. Similarly draw lines and curves and use equal command to equal them. 6. Draw circles at the given point. 7. Use dimension command to adjust the dimensions of different lines and curves. 8. Use protrusion command to draw the sketch.