Download as pdf or txt
Download as pdf or txt
You are on page 1of 3

Petroleum Plant Design

Site Preparation Oil and Gas Well Area


November 07, 2014

After All the surveys carried out and the data obtained indicate the
area contains oil or gas reserves stored in reservoirs favorable, the
next stage is no land preparation (site preparation). Land preparation
herein include social aspects, licensing and technical environmental
impact control.

During the drilling process must comply with codes, standards and
regulations berkalu country and local area. In the area of land
preparation to be released should refer to the applicable safety
standards such as OSHAS, NFPA, kupak etc.

In Indonesia's Pertamina safety standards refer to KUPAK. In kupak


regulates the safety distance between the wells to a safe area and the
distances between facilities or equipment in the area of the well. Of
the minimum distance KUPAK disaratkan obtained the minimum
width should be released or the extent of the required one well or
cluster.

All the equipment used during the drilling process such as RIG, heavy
equipment must be feasible and certiRed according to safety
standards issued by the authorities. For personnel must use personal
protective equipment such as helmet standards, google glass, safety
boots and full body hardness what if this is altitude.

Oil and Gas

Enter your comment...

Popular posts from this blog

OPEN AND CLOSED DRAINS SYSTEM


December 05, 2014

The drain system design is based on segregated


systems, described below. The Open Non-
Hazardous Drainage System provide drainage for …

READ MORE

CLOSED DRAIN DRUMS CALCULATION NOTE


December 09, 2014
1.0 INTRODUCTION
The purpose of this calculation note is to provide
the preliminary sizing of Closed Drain Drums at the…

READ MORE

DESIGN LOAD AND COMBINATION LOAD


November 14, 2014

1.1General …

READ MORE

Powered by Blogger

Theme images by Michael Elkan

Blog Archive

Labels

Report Abuse

You might also like