Professional Documents
Culture Documents
Motor Tutorial
Motor Tutorial
TUTORIAL
1. We measured a plastic container on some wood, cut it and made a base. We then
attach two pieces of wood to make a structure to hold all the wire and everything
else.
2. We drilled a hole in the top piece of wood a hammered in a nail with about an
inch sticking out then we wrapped the wire around the nail with about 5 inches
left on each side then stuck one side through the hole drilled earlier and bended it
into a hook shape.
Motor Tutorial
Ainsley, Annika, Grace
2018
3. We used a chain of rings as an extension then took a long piece of copper and
hooked it onto it witch made it hang down into the container.
4. We took a piece of aluminum and hung it over the edge of the container then we
put a stack of magnets in the middle of the container.
5. Next we filled the container with 2 cups of warm water and two tablespoons of
salt.
6. We attached the magnet wire to the ends to a 9 volt battery then onto the loose
end of the copper wire, and the piece of aluminum.