1. There are four main losses of prestress over time: elastic shortening, shrinkage of concrete, creep of concrete, and relaxation of steel.
2. Elastic shortening occurs due to the elastic deformation of concrete under the prestressing force.
3. Creep is the time-dependent deformation of concrete under a sustained load, which causes additional loss of prestress.
In The Post Tensioned Beams Several Cables Are Provided. The Cables Are Stretched in Succession. When A Cable Is Stretched, This Cable Frictional Loss Due To Wobble Effect Is
1. There are four main losses of prestress over time: elastic shortening, shrinkage of concrete, creep of concrete, and relaxation of steel.
2. Elastic shortening occurs due to the elastic deformation of concrete under the prestressing force.
3. Creep is the time-dependent deformation of concrete under a sustained load, which causes additional loss of prestress.
1. There are four main losses of prestress over time: elastic shortening, shrinkage of concrete, creep of concrete, and relaxation of steel.
2. Elastic shortening occurs due to the elastic deformation of concrete under the prestressing force.
3. Creep is the time-dependent deformation of concrete under a sustained load, which causes additional loss of prestress.
1. There are four main losses of prestress over time: elastic shortening, shrinkage of concrete, creep of concrete, and relaxation of steel.
2. Elastic shortening occurs due to the elastic deformation of concrete under the prestressing force.
3. Creep is the time-dependent deformation of concrete under a sustained load, which causes additional loss of prestress.
For steel and steel 0.30 For steel and lead 0.25 1. Friction between the tendon and its surrounding material is the length effect and is sometimes described as 6. wobbling effect. Friction due 7. If N is the normal component to length effect depends on of F, we have the length, stress in the tendon (cable) and the 8. coefficient of friction between 9. If is the coefficient of
the contact materials. friction, frictional loss =
2. Curvature effect is caused by dF=
the friction due to designed 10. Frictional loss due to
curvature of the cable. Loss wobble effect is calculated as
due to these effects is 11. dF = –KFds
estimated as follows: 12. where K is coefficient
3. Consider a small length of of wave effect.
the cable. Let ds be its length 13. Therefore, total
and R be the radius of frictional loss = dF
curvature. (Figure below). =
4. Let be the angle
14. or subtended at the centre by 15. if F is the prestress at a the length ds. distance S subtending an 5. Let F be prestress at one end angle , integrating the and F – dF the prestress at above equation between the other end. limits F and Fx, we have 16. 17. Value of and K may be taken as follows: 18. There are several allowable steel stress of fs = 0.5 fy = means of reducing or 20,If prestress is measured at balancing the loss of the time of pulling the wire, prestress due to creep. the stress is termed as the 19. In the post jacking stress. Deducting the tensioned beams several loss due to anchorage take- cables are provided. The up and friction, initial cables are stretched in prestress is obtained. succession. When a cable Effective stress is usually the is stretched, this cable initial stress minus other four suffers no loss, but the losses namely: cable stretched before 21. Loss due to suffers a loss due to 22. girders By AASHTO prestress in the cable specifications, an allowable concrete being stretched. Thus the stress of fc = 0.40 fc ’ = 1200 psi And an cable which is stretched allowable steel stress of fs = 0.5 fy = first will suffer maximum 20,If prestress is measured at loss due to stretching of the time of pulling the wire, (n – 1) cables where n is the stress is termed as the the total number of jacking stress. Deducting the cables. The cable loss due to anchorage take- stretched last will not up and friction, initial suffer any loss. To prestress is obtained. calculate the loss due to Effective stress is usually the elastic shortening, loss in initial stress minus other four the first cable is losses namely: calculated and half of this 23. Loss due to value is taken as the 24. average loss of all the 25. vc) Creep of Concrete: cables. 26. Creep is the time 20. girders By AASHTO dependent deformation due specifications, an allowable concrete to permanent force. In stress of fc = 0.40 fc ’ = 1200 psi And an prestressed concrete, prestress is the permanent girders By AASHTO specifications, an allowable force in the member, causing concrete stress of fc = 0.40 fc ’ = 1200 psi And compressive stress at the an allowable steel stress of fs = 0.5 fy = 20,If level of steel. Hence there is prestress is measured at the time creep strain in the member. of pulling the wire, the stress is termed as the jacking stress. 27. relaxation of steel Deducting the loss due to TOTAL LOSS OF PRESTRESS: anchorage take-up and friction, 28. elastic shortening initial prestress is obtained. 29. shrinkage of concrete Effective stress is usually the initial stress minus other four losses 30. creep of concrete namely: 31. relaxation of steel Loss due to and Specifications Clear Span 48 ft Clear width 29 ft Live Loading HS20 Concrete strength fc ’ 3000 psi Future protective cover 15 pf Grade 40 reinforcement The bridge will consist of six c girders By AASHTO specifications, an allowable Elastic strain = concrete stress of fc = 0.40 fc ’ = 1200 psi And an allowable steel stress of fs = 0.5 fy = 20,If is the stress in concrete at the prestress is measured at the time level of steel. of pulling the wire, the stress is Loss in prestress = creep strain termed as the jacking stress. x Deducting the loss due to anchorage take-up and friction, initial prestress is obtained. Effective stress is usually the initial stress minus other four losses namely:
In The Post Tensioned Beams Several Cables Are Provided. The Cables Are Stretched in Succession. When A Cable Is Stretched, This Cable Frictional Loss Due To Wobble Effect Is