Download as doc, pdf, or txt
Download as doc, pdf, or txt
You are on page 1of 4

Title

Font: Times

Font: Times
Paper Format for the Proceeding IMAT 2012  Size: 16pt
Style: Bold
Size: 12pt
Style: Bold
AuthorAa, AuthorBb
a
Faculty * Program Studi*
Institut Teknologi Del, Sumatera Utara 22381
Font: Times
E-mail : authora@@ui.edu
Size: 9pt
a
Style: Italic
Faculty * Program Studi*
Institut Teknologi Del, Sumatera Utara 22381
Font: Times
E-mail : authorb@ui.edu
Size: 9pt
Style: Italic
ABSTRACT a   paper   for and   not   more   than will  be  added  in the
publication in IMAT six.  The   text   should final publications. 
Font: Times Your   paper   abstract 2009   conference be   typed   in   single
Size: 10pt should   convey   the proceedings   so   that space,   using   a   font 2.2 Abbreviations
Style :Italic and Acronyms
importance   of   your there is a consistency similar   to   the   one
research in a concise among papers. These used   in   this   text
Define abbreviations
and   logical   manner. instructions   give (Times,   10   points). and acronyms the
The   abstract   is   a guidance   on   layout, Paragraphs should be first time they are
synopsis   of   the style,   illustrations separated   by   single used in the text, even
Font: Times original   study   that and   references   and spacing.  Each after they have
Size: 10pt already been defined
Style: Bold addresses   the serve as a model for manuscript   should in the abstract.
research problem, the authors   to   emulate. not   exceed  EIGHT Abbreviations such
information   and Please   follow   these (8)   PAGES as IEEE, SI, MKS,
methods   used   to specifications closely including CGS, ac, dc, and rms
address   this  problem as   papers   which   do do not have to be
illustrations   and defined.
and   your not   meet   the tables.   The   paper Abbreviations that
conclusions.  It standards   laid   down,
must   be   submitted incorporate periods
should   present   only will not be published. should not have
as   WORD
key   points   without spaces: write
documents.  “C.N.R.S.,” not “C.
exceeding a length of 2.   STYLE   OF
N. R. S.” Do not use
200   words.  The   use MANUSCRIP 2.1 Sections   and abbreviations in the
of   technical   jargon
T Subsections
title unless they are
and  the   citing   of unavoidable.
references   should   be
Manuscripts must be Sections   and
avoided.  3.   TABLES   AND
in   English   and subsections   should
prepared   on  A4   size be   numbered   and FIGURES
Keywords
paper   (210mm   X titled as 1, 2, etc. and
Font: Times 297mm)   in   two 1.1,   1.2,   2.1,   2.2, Figures   should   be
Size: 10pt Example: column­format   with labeled with "Figure"
Style :Italic 2.2.1,   etc.   Capital
Hybrid 2.5cm   margins   from and   tables   with
letters should be used
syste top   and   bottom,   and "Table"   and   should
for the section titles.
m,op 1.5cm   from   left   and be   numbered
For   subsections,   the
timiz right, leaving a gutter sequentially,   for
first   letter   of   each
ation width of 0.5 between example,   Figure   1,
word   should  be  in
,auto columns.  Figure   2   and   so   on
capital   letter   and
nom (refer  to table 1 and
followed   by   small
ous  Centered at top of the figure 1). The figure
letters. 
Font: Times
first   page   should   be numbers   and   titles
Size: 11pt 1. the   complete   title   of 2.1.1 Identificati should   be   placed
Style: Bold
INTRODUCT the   manuscript.   This below   the   figures,
on
is   followed   by   the and   the   table
ION
abstracts   under   the Please   avoid numbers   and   titles
heading including  headers, should   be   placed   on
This   guide   provides
ABSTRACT, footers   or   page top of the tables. The
details   to   assist
keywords   under   the numbers   in   your first letter of the title
authors   in   preparing
heading  Keywords submission.   These should   be   placed   in
the   middle   of   the Equations  must   be publication should be singular. In American
page between the left typed, not inserted. cited as “in press” English, periods and
[5]. commas are within
and   right   margins.
Capitalize only quotation marks, like
Tables,   illustrations Example: the first word in a “this period.” A
and   the paper title, except for parenthetical
corresponding   text Z = c0 + c1 X1 + c2  proper nouns and statement at the end
should   be   placed   on
Font: Times
X2 + c3 X3 + c4 X4  element symbols. For of a sentence is
Size: 11pt papers published in
the same page as far
Style: Bold (1) punctuated outside of
translation journals,
as   possible. the closing
please give the
Otherwise   they   may parenthesis (like
English citation first,
this). (A parenthetical
be   placed   on   the 5.   CITATIONS followed by the
original foreign- sentence is
immediate   following
AND language citation [6].
punctuated within the
page.  Its size should parentheses.) Use the
be   smaller   than   the REFERE word “whereas”
type area. NCES instead of “while”
6. DISCUSSION (unless you are
Font: Times
Size: 9 pt Table 1: Center table Number citations referring to
Style: italics consecutively in Use a zero before simultaneous events).
captions above
square brackets [1]. decimal points: Prefixes such as
the tables. “0.25,” not “.25.”
The sentence “non,” “sub,”
punctuation follows Use “cm3,” not “cc.” “micro,” “multi,” and
solvent T (°C) Indicate sample
the bracket [2]. Refer “ultra” are not
Font: Times CDCl3 RT dimensions as “0.1
simply to the independent words;
Size: 8-10 pt CDCl3 20 cm ´ 0.2 cm,” not
reference number, as they should be joined
CHCl3 10 “0.1 ´ 0.2 cm2.” The
in [3]. Do not use to the words they
CHCl3 20 abbreviation for
“Ref. [3]” or modify, usually
“reference [3]” “seconds” is “s,” not
without a hyphen.
except at the “sec.” When
There is no period
beginning of a expressing a range of
after the “et” in the
sentence: values, write “7 to 9”
or “7-9,” not “7~9.” Latin abbreviation
“Reference [3] shows
Spell units when they “et al.” (it is also
... .”
appear in text: “…a italicized). The
Please note that the few henries,” not “… abbreviation “i.e.,”
references at the end a few H.” means “that is,” and
of this document are the abbreviation
in the preferred 7. CONCLUSION “e.g.,” means “for
Figure 1: Description example” (these
is placed right below referencing style.
Give all authors’ Finally, you are abbreviations are not
the figure
names; do not use responsible for italicized).
“et al.” unless there language as editors
4. EQUATIONS are six authors or will not check it. Do
more. Use a space a spell and grammar
after authors' initials. ACKNOWLEDG
When   numbering check. This is
equations,   enclose
Papers that have not available in Word. If MENT
been published, even English is not your The preferred
numbers   in if they have been native language, get spelling of the word
parentheses   and submitted for “acknowledgment”
a professional proof-
place   flush   with publication, should in American English
reader to help if
right­hand margin of be cited as is without an “e”
“unpublished” [4]. possible.
the   column. after the “g.” Use the
Papers that have been The word “data”
singular heading
accepted for is plural, not
even if you have Kollert, A. Bittel, work  as   an
many and K. Bachmann,
“Prenatal undertaking   to
acknowledgments.
recording of fetal publish the paper.
heart action with
REFERENCES magnetocardiograp
hy” (in German), Prior   to   final
Zeitschrift für acceptance   of   the
[1] D. J. Beebe,
“Signal conversion
Kardiologie, vol. paper,   authors   are
87, no. 2, pp. 111–
(Book style with
8, 1998. required   to   confirm
paper title and in   writing   that   they
editor),” in
Biomedical Digital hold   all   necessary
COPYRIGHT
Signal Processing, copyright   for   their
W. J. Tompkins, paper   and   to   assign
Ed. Englewood All papers submitted
Cliffs, NJ: this   copyright   to   the
Prentice-Hall, must   be   original, Conference
1993, ch. 3, pp. unpublished   work Organizer.
61–74. not   under
[2] M. Akay, Time
Frequency and consideration   for
Wavelets in publication
Biomedical Signal elsewhere.   Authors
Processing (Book
style). Piscataway, are   responsible   to
NJ: IEEE Press, obtain   all   necessary
1998, pp. 123–135. permission   for   the
[3] G. B. Gentili, V.
Tesi, M. Linari, reproduction   of
and M. Marsili, “A tables,   figures   and
versatile images   and   must   be
microwave
plethysmograph appropriately
for the monitoring acknowledged.   The
of physiological paper   is   not
parameters
(Periodical style),” defamatory;   and   the
IEEE Trans. paper   does   not
Biomed. Eng., vol. infringe   any   other
49, no. 10, pp.
1204–1210, Oct. rights   of   any   third
2002. party.
[4] V. Medina, R.
Valdes, J. Azpiroz,
and E. Sacristan, The   authors   agree
“Title of paper if that   the   Technical
known,” Committee’s
unpublished.
[5] E. H. Miller, “A decision   on   whether
note on reflector to   publish   the   paper
arrays (Periodical in   the   Conference’s
style—Accepted
for publication),” proceedings  shall   be
IEEE Trans. final.   The   authors
Antennas should   not   treat   any
Propagat., in
press. communication   from
[6] T. Menendez, S. the   Technical
Achenbach, W. Committee   members
Moshage, M. Flug,
E. Beinder, A. who   reviewed   their

You might also like