Volkswagen Golf MK6
PDC Parking Distance Park Pilot - Front + Rear
installation manual v. 1.0.
Included:
3 pes] Wirings
0,9, 6, 1 pes| Control unit
7 pes| PDC Button
0,6, 6,5, Tpes| Sensors
8 pes| Holders
2 pes| Buzzer
_/_, 1 pcs| Installation Manual
i < 4
Y SLD Ss)
am : p fF (Toy
: | in
Wwww.carsystems.euUnplug and remove battery, then unscrew —_Pull ou! the sides of bumper and pull whole
four marked bolts to remove front grille. part to the front to take it off.
Unscrew bolts behind mudguards and at the
bottom of the front bumper. Remove front
bumper.
3 4
Drill 18mm holes at the marked positions on Attach bumper and screw it back. Pull and tie
the front bumper. (note: drill only four holes, wires near battery holder.
side marks are for Park Line Assist sensors). Rear sensors installation is similar.
Mount holders to bumper and attach sensors
with wiring hamess.
2 vor carsystoms.etRemove rear lights and unscrew bolts holding
rear bumper. Slide whole bumper to back side
of car.
Drill 18mm holes at marked positions and
attach sensors to the rear bumper. Mount
wiring and sensors
Six pole connector pull through firewall to the
engine compartment.
Beige connector pull near gear shift lever,
Red wire connect to +12v after ignition in
fusebox. Orange wire connect to the Can Hi
(pin 16 in Can gateway module).
Brown wire connect to the Can Low
(pin 6 in Can gateway module]
y
Pull the wires through the marked hole to the
inside of car. Install POC module at the left side
of the trunk behind covers.
Plug in three plugs to the module. Attach
round connector to the ground point
install rear buzzer at the right side of trunk
behind cover. Other wires pull to the front of
car and tie as fabric installation.
rE
Grey wire solder to the illumination signal from
other buttons in eg. ESP. Brown wires solder to
the ground signal plug in Park button.
install front buzzer near A-pillar. Plug in front
bumper wiring to the six pole connector.
Connect battery and use VCDS to code
modules.
Fo wrnsarsysiomscnled Seu Ls
Add to Can Gateway (19 - Can Gateway) installation list position number 10- Park Assist.
-sink ‘a
eee nat Zanes korsgnie
0G. ascharuce
4 katate teow
(rayon myiaing kotguag]
—
(5 Parga ps,
(2 no-kameacads
13 Res tao
(14 ncanserrnts
Zs. soag
(2 19-o weroaney
(Bl esistatniow
C118: Ogres somocn
19 can Gsiooer
5 te Renee oatla
1520 Ae Sanaon
Cn aan
25. imeniaar
(C2e-ciearseaset
(5 2E- ei Pie 3
Bm Blocaroroci
(5135. ramige ta Wet
Open block 10-Park Assist > Coding > Long Coding helper > Code the pde module as follows:
Serena = a
a vcDS
Wiybor steronnilka
[Bhecne | Neped | Podwoze | UMadhemfort | Elektonixs 1 | Elekronika 2 |
(asin | [athens]
(Roiiienee] [Totem]
Dostgpbexposodi
Stra sissomten, | [Saka PitGolf - ppc Parking Distance Park Pilot - coding instructions
Sear een
rte hea vcDs
Praancan day ze erika
senses seen
Numervas——_SKO'918 475 argon] PARKHILFE aK HO) ant?
Kedowenie ___Kodowanve diugie Kod sseyey! mp 000 WS@ 00000
Eat
Ese
Funkeiepodstswone
Teaateemacemet
ye ;
{sbipeniarve= 08) [Me rxsz-10] ‘Aaa
oe Lo
‘iyriaees
[Tena e ce [ caseninen
anise odcytu, pot
Eterna enor
Wenec| Pos cryanebi| Care) Pan
[Nowe kosowrone jst atmatycmieFoxioweane Xo MCDB. w cht rama Coe [AES ‘Boake