Professional Documents
Culture Documents
1.2. TK S014M
1.2. TK S014M
Connectivity supervision
This new device has the ability to monitor the status of the connection of the
wiegand reader. An alarm is sent when the connection is lost due to a cut of
the power connection of the reader, due to the absence of the reader or in
case of short circuit.
Tampering supervision
An alarm is sent when the reader is opened or disconnected from wall and in
case of short or cut on the tamper wire.
MAJOR BENEFITS
Easy to install:
• The direct LON connection and embedded I/O simplifies installation
and engineering and reduces the number of system devices.
Flexibility:
• Select the reader you prefer in terms of design or re-use existing devices
for cost-saving purposes.
Investment protection:
• As your network grows, the solution can scale and devices can be re-used.
• Coexist on systems using TK_S014
• Supported by both TS_AC01 and TS2 controllers
• Standard DIN/Omega • Echelon “LON” Device • Internal I/O for door • Identifies failures in
RAIL 35 control readers connected
• Tamper-proof housing
• TK_S014M supports • Supervised inputs
• Management of the
Two “Wiegand 7 Wire”
Wiegand readers • RoHS compliant, so
connected card
tampers environment
readers and the I/O
respectful
associated with a • Management of device
single door external tamper
TK_SO14M Specifications
TECHNICAL PHYSICAL
PARAMETER VALUE MOUNTING Standard DIN/omega rail
12V +/-15% 70mA [nominal internal]
DC POWER SUPPLY SIZE (LXWXH) 105 x 93 x 61 mm
[up to 2.5A when driving power loads]
Unshielded twisted-pair cable in free topology connection WEIGHT
LONWORKS® CONNECTION
FT3150 smart transceiver 78Kbps 0,2 Kg
(INCLUDING CARTON BOX)
Type: Controlled on 4 states (open, close, cut, short)
Number: 2 1 internal switch (against opening);
Supply Voltage: 0V...+10V ANTI-TAMPERING possibility to connect a further
CONTROLLED INPUTS Supply current: 0…3 mA external tamper (not provided)
Voltage (absolute max): -24V...+40V
Wire length connection: total resistance < 10 Ohm – not shielded ENVIRONMENTAL
Min detection time: 250 ms
Type: Controlled on 3 states (normal, alarm, short) ENVIRONMENTAL
READERS TAMPER INPUTS Number: 2 TEMPERATURE FOR -10 ÷ 55°C
Min detection time: 250 ms CORRECT OPERATION
Type Wiegand (normally high)
STORAGE TEMPERATURE -20°C ÷ 70°C
Number: 2
Voltage: 0V...+5V nominal (TTL) +14V Max STORAGE AND OPERATING
Timing BIT Pulse width: min 50us – max 10ms 0 ÷ 90% not condensing
HUMIDITY
BIT Interval time: min 500us – max 20ms
Electromagnetic Compatibility
D0 Directive (2014/30/EU)
BIT PULSE
BIT PULSE
Made In Italy
BIT INTERVAL BIT INTERVAL
BIT PULSE
UL60950
E221152