Professional Documents
Culture Documents
Corn Agronomy: Castor Bean
Corn Agronomy: Castor Bean
Corn Agronomy: Castor Bean
Home Season Management Silage Crops Programs Home | Crops | Legume Pulses | Castor Bean
Castor Bean
E. S. Oplinger1, E. A. Oelke2, A. R. Kaminski1, S. M. Combs1, J. D. Doll1, and R. T. Schuler1
1Departments of Agronomy, Soil Science and Agriculture Engineering, College of Agricultural and Life Sciences and
Cooperative Extension Service, University of Wisconsin-Madison, WI 53706.
2Department of Agronomy and Plant Genetics, University of Minnesota, St. Paul, MN 55108.
May, 1990.
I. History:
The castorbean plant (Ricinus communis) has been cultivated for centuries for the oil produced by its seeds. The Egyptians
burned castor oil in their lamps more than 4,000 years ago.
Grains Thought to be native to tropical Africa, the plant is a member of the spurge family. The seeds with hulls removed contain 35 to
55% oil. The seeds, leaves, and stems of the plant contain ricin and ricinine, which are poisonous to humans and animals.
Amaranth
Eating a castorbean causes nausea, and eating several may cause death. These toxic compounds are not present in the oil.
Barley
Castorbeans are grown on a limited scale in the United States. Demand for the crop peaked in the early 1950s, when the
Buckwheat
federal government wished to increase supplies of castor oil for military applications in the event of a national emergency. The
Comfrey government guaranteed farmers, particularly in the Southwest, ten cents per pound for the seeds, which were grown under
Kochia contract with castor oil processors.
Millets The castorbean plant grows well in soil of medium texture. It is best adapted to southeastern Kansas, Missouri, southern
Oat Illinois, southern Indiana, Tennessee, Kentucky, and parts of Oklahoma and Texas. With irrigation, it also grows well in the
Southwest.
Popcorn
Quinoa
Rye II. Uses
Sorghum In the United States, castor oil has been used by the military in aircraft lubricants, hydraulic fluids, and in the manufacture of
Spelt explosives. It has also been used in the synthesis of soaps, linoleum, printer's ink, nylon, varnishes, enamels, paints, and
electrical insulations. Textile scientists have used sulphonated castor oil in the dyeing and finishing of fabrics and leather. The
Triticale
most infamous application of castor oil may have been as a purgative popular for the treatment or prevention of many
Wheat ailments in the first half of the twentieth century.
Wild Rice
Castorbean meal is included as a protein source in feed for swine. Castorbean pomace, or meal, the residue left after the oil
Legume Pulses has been extracted from the seeds, has been included in mixed fertilizer. This product contains the ricin and ricinine from the
seeds. Certain varieties of castorbean plants are grown as ornamentals.
Adzuki Bean
Castor Bean
III. Growth Habits:
Chickpea
In the tropics, the castorbean plant is a perennial. It is grown as an annual in temperate regions, however, requiring a growing
Cowpea
season of 140 to 180 days.
Fababean
Field Bean Germination is slow. Seedlings will emerge 10 to 21 days after planting. Commercial varieties grow to a height of 3 to 10 ft.
Field Pea The plant consists of several stems or branches, each terminated by a spike. The mature spike is six to 12 in. long. In some
Guar varieties, female flowers are on the upper part of the spike and male flowers on the lower part. Other varieties have male and
female flowers interspersed on the spike. Varieties with spikes of only female flowers have made possible the production of
Hairy Vetch hybrid seed. Male flowers drop off the spike after pollination.
Lentil
The lower spikes on the plant mature first, followed by the upper spikes. Each spike bears 15 to 80 capsules, which may be
Lupine prickly or smooth on the outer surface. The capsules, which develop from the female flowers, contain three seeds each and
Mungbean explode when ripe.
Peanut
The seeds may be egg-shaped, oblong, or round, usually with an enlargement on one end, called the caruncle. Seeds vary in
Oil Seeds size, but most commercial varieties average 1,000 to 1,500 seeds/lb.
Canola The plant is not a legume, as its name would imply. It has no soil-improving value other than that of any rotation crop.
Crambe
Flax IV. Environment Requirements:
Jojoba
A. Climate:
Meadowfoam
Mustard Castorbeans grow best where temperatures remain fairly high throughout the growing season of 140 to 180 days. The soil
must be able to warm up early in the spring. The seed may fail to set, however, if the temperature stays above 100oF for an
Psyllium
extended period.
Safflower
Sesame
B. Soil:
Soybean
http://corn.agronomy.wisc.edu/Crops/CastorBean.aspx 1/3
2/1/2018 Castor Bean
Sunflower The crop requires a loamy soil of medium texture. Castorbeans do well on either alkaline or acid soils, as long as the subsoil is
Vernonia permeable and there is good drainage. Seed will not set if soil moisture is inadequate. Castorbeans should not be planted in
an area that is subject to erosion.
Other
B. Seeding Date:
Castorbeans should be planted in early May, about the same time as corn. Seedlings will emerge in 10 to 21 days.
Because castorbeans are oily and easily broken, they can clog machinery and cause irregular spacing. Most corn planters with an air metering system
should perform well. Planters using metering plates will require plates with proper cell size. Always check the planting unit to ensure that excessive
bean cracking or crushing is not occurring during planting.
The amount of nitrogen required by castorbeans depends on the soil organic matter content as shown in Table 1. Preplant and sidedress applications of
nitrogen may be beneficial at the higher application rates or on lighter-textured soils.
In general, castorbeans require the same amount of nutrients as other low-demand field crops. For typical silt loam soils testing in the optimum range
(6 to 10 ppm P; 81 to 100 ppm K), approximately 20 lb P2O5 and 40 lb K2O should be applied per acre. If soil tests are below optimum, approximately
5 lbs P2O5 and 20 to 30 lb K2O should be applied in addition to the previous amounts. Castorbeans do not generally respond to phosphorus, and excess
soil phosphorus levels can actually decrease yields. Therefore, do not apply P2O5 except where soils test in the optimum or below optimum level for
extractable P.
E. Variety Selection:
Castorbean varieties have been developed to produce large yields of seed with a single harvest. The tall varieties may reach a height of 10 ft or more.
The dwarf types seldom exceed four or five ft.
F. Weed Control:
The slow emergence and early growth of castorbeans means the plants are not strong competitors against weeds. Rotary hoeing during the first few
weeks after planting, followed by row cultivation should provide acceptable control. Because the main lateral roots of the castorbean plant are near the
soil surface, cultivation should be shallow. At the present time, herbicides are not registered for controlling weeds in castorbeans in Wisconsin or
Minnesota.
http://corn.agronomy.wisc.edu/Crops/CastorBean.aspx 2/3
2/1/2018 Castor Bean
help prevent disease problems, a good rotation program and treatment of seed with a fungicide prior to planting are recommended. Thiram is the only
registered seed treatment fungicide.
I. Harvesting:
The castorbean crop is ready for harvesting when all the capsules are dry and the leaves have fallen from the plants. Ideally, harvesting should begin
10 to 14 days after the first killing frost. If killing frosts will not permit completion of harvesting before winter, a chemical defoliant may be applied 10
to 15 days ahead of the desired harvest date. Defoliants tend to reduce yields, however. Delay in harvesting after the crop is ready may result in losses
from "shattering," in which the seeds pop out of the capsules.
Since castorbeans are very susceptible to cracking and splitting during harvest, adjustment of the combine cylinder speed and cylinder-concave
clearance is very important. Usually, a low cylinder speed and wide cylinder concave clearance are recommended. Combine operators should frequently
inspect harvested beans for breakage.
Weeds cause problems in the castorbean harvest. They may clog machinery or push in front of the harvester and cause shattering of the castorbeans.
Volunteer corn plants present no special problem in the harvesting operations, but do add foreign material to the yield.
After harvest, break up the stalks mechanically and work them into the soil. The stalks deteriorate rapidly and furnish organic matter. Castorbean hulls,
which are scattered over the field during harvest, are about equal to barnyard manure in fertilizer value.
Seeds left in the field after harvest may cause a volunteer problem in the next year's crop. Waiting until seeds germinate and then disking the young
plants down will prevent this to some extent. Follow castorbeans with a row crop or a grain crop, for which the volunteer castorbean plants will not
present a problem.
University of Wisconsin, 1575 Linden Drive - Agronomy, Madison WI 53706 (608) 262-1390
If you would like to subscribe (or unsubscribe) to updates during the growing season, click here.
For a list of website updates, click here. Send comments about this website to Joe Lauer.
© 1994-2018 Board of Regents of the University of Wisconsin, Division of Cooperative Extension of UWEX.
http://corn.agronomy.wisc.edu/Crops/CastorBean.aspx 3/3