Professional Documents
Culture Documents
Assignment 3 & Solution
Assignment 3 & Solution
Q.1 The effective length of butt weld should not be less than 1
(a) four times the size of weld
(b) twice the size of weld
(c) thrice the size of weld
(d) five times the size of the weld
(a) 5 N/mm2
(b) 6 N/mm2
(c) 9 N/mm2
(d) 8 N/mm2
6𝑀
(b) 𝑛=√
𝑝𝑛’𝐵𝑠𝑑
6𝑀
(c) 𝑛=√
𝑝𝐵𝑠𝑑
6𝑀𝑝
(d) 𝑛=√
𝑛’𝐵𝑠𝑑
𝐵𝑠𝑑
(b) 𝑛=
𝑃
𝑃
(c) 𝑛=
𝐵𝑠𝑑
(d) 0
Q.8 Which one of the following is the most critical bolt in the joint shown
in the figure given below? 2
300 kN
5 1
6 2
7 3
8 4
(a) Bolt 1
(b) Bolt 4
(c) Bolt 5
(d) Bolt 8
Q.10 When the load line coincides with the centroid of the bolt group, the
bolts are subjected to 1
(a) shear only
(b) tension only
(c) bending only
(d) shear as well as tension
Q.1 The effective length of butt weld should not be less than 1
(a) four times the size of weld
Solution hints:
Lec 11 Design of Butt Welds, Slide No. 6.
Solution hints:
Effective throat thickness = 0.7×5 = 3.5 mm
𝑃
𝑞=
2𝜋𝑟𝑡
𝟔𝑴
(b) 𝒏=√
𝒑𝒏’𝑩𝒔𝒅
Solution hints:
See lecture 14 Design of eccentric connection, slide no 2.
300 kN
5 1
6 2
7 3
8 4
(b) Bolt 4
Solution hints:
In the case of inclined load, a bolt nearest to the load axis will be
critical. Extending the line of action of the load, the nearest bolt is bolt 4.
Q.9 Polar moment of inertia of weld, Ip is equal to 1
(c) Ix + Iy
Solution hints:
See lecture 15 Design of eccentric connection, slide no 4
Q.10 When the load line coincides with the centroid of the bolt group, the
bolts are subjected to 1
(a) shear only