Professional Documents
Culture Documents
Edb - 7580022 - GBR - en Isolating Switching Amplifier 2-Channel IMX12-DI01-2S-2T-0 24VDC CC Turck
Edb - 7580022 - GBR - en Isolating Switching Amplifier 2-Channel IMX12-DI01-2S-2T-0 24VDC CC Turck
2-channel
IMX12-DI01-2S-2T-0/24VDC/CC
Sensors according to EN 60947-5-6 (NAMUR) The device can be used in safety circuits up to ■ ATEX, IECEx, NEPSI, cULus, INMETRO,
or potential-free contacts can be connected to SIL2 (high and low demand according to IEC Kosha, TIIS, TR CU, DNV, GL
the IMX12-DI01-2S-2T-0/24VDC/CC isolating 61508). ■ Installation in zone 2
switching amplifier. The device is equipped
The device is equipped with removable cage ■ SIL 2
with intrinsically safe input circuits and can be
clamp terminals. ■ 2 transistor outputs (ð 10kHz)
installed in zone 2. A DIP switch on the device
allows to toggle between 2-channel or 1-chan- ■ Switchable: 2-channel or signal dou-
nel operating mode with signal doubling. The bling
output circuits are equipped with two poten-
■ Output mode adjustable (NO/NC mode)
tial-free transistors with high cut-off frequen-
cy (10 kHz). The device complies with the re- ■ Input circuits monitored for wire-break/
quirements of the NE21. short-circuit (ON/OFF switchable)
■ Complete galvanic isolation
The devices feature DIP switches on the
front. This allows to select between the output ■ Removable cage clamp terminals
mode, the input circuit monitoring, as well as
toggle between signal duplication and 1-chan-
nel operation. When using mechanical con-
tacts, either line monitoring must be switched
off or the contact must be wired with resistors
(see wiring diagram).
1/3 Hans Turck GmbH & Co.KG ñ D-45472 Mülheim an der Ruhr ñ Witzlebenstraße 7 ñ Tel. 0208 4952-0 ñ Fax 0208 4952-264 ñ more@turck.com ñ www.turck.com
Isolating switching amplifier
2-channel
IMX12-DI01-2S-2T-0/24VDC/CC
Dimensions
Type designation IMX12-DI01-2S-2T-0/24VDC/CC
Ident no. 7580022
Galvanic isolation
Test voltage 2.5 kV
Input 1 to output 1 375 V peak value acc. to EN 60079-11
Input 2 to output 2 375 V peak value acc. to EN 60079-11
Input 1 to supply 375 V peak value acc. to EN 60079-11
Input 2 to supply 375 V peak value acc. to EN 60079-11
Output 1 to supply 100 V RMS acc. to EN 50178 and EN 61010-1
Output 2 to supply 100 V RMS acc. to EN 50178 and EN 61010-1
Output 1 to output 2 100 V RMS acc. to EN 50178 and EN 61010-1
Indication
Operational readiness green
Switching state Yellow
Error indication red
Edition • 2018-04-02T08:15:14+02:00
2/3 Hans Turck GmbH & Co.KG ñ D-45472 Mülheim an der Ruhr ñ Witzlebenstraße 7 ñ Tel. 0208 4952-0 ñ Fax 0208 4952-264 ñ more@turck.com ñ www.turck.com
Isolating switching amplifier
2-channel
IMX12-DI01-2S-2T-0/24VDC/CC
3/3 Hans Turck GmbH & Co.KG ñ D-45472 Mülheim an der Ruhr ñ Witzlebenstraße 7 ñ Tel. 0208 4952-0 ñ Fax 0208 4952-264 ñ more@turck.com ñ www.turck.com