This document provides technical specifications for an underground drilling unit, including:
It has a drilling range of 1800 mm and can drill at angles between 0-180 degrees with a maximum torque of 800 Nm. It is 6000 mm long, 2000 mm wide, and 1800 mm tall when transported.
Key systems include hydraulic main pumps from 100-140 cc, a hydraulic oil tank holding 120-350 liters, an electric motor up to 55 kW, and a high pressure water pump that can produce 100-160 bar of pressure.
The drilling unit is designed for extended use in underground and Arctic conditions.
This document provides technical specifications for an underground drilling unit, including:
It has a drilling range of 1800 mm and can drill at angles between 0-180 degrees with a maximum torque of 800 Nm. It is 6000 mm long, 2000 mm wide, and 1800 mm tall when transported.
Key systems include hydraulic main pumps from 100-140 cc, a hydraulic oil tank holding 120-350 liters, an electric motor up to 55 kW, and a high pressure water pump that can produce 100-160 bar of pressure.
The drilling unit is designed for extended use in underground and Arctic conditions.
This document provides technical specifications for an underground drilling unit, including:
It has a drilling range of 1800 mm and can drill at angles between 0-180 degrees with a maximum torque of 800 Nm. It is 6000 mm long, 2000 mm wide, and 1800 mm tall when transported.
Key systems include hydraulic main pumps from 100-140 cc, a hydraulic oil tank holding 120-350 liters, an electric motor up to 55 kW, and a high pressure water pump that can produce 100-160 bar of pressure.
The drilling unit is designed for extended use in underground and Arctic conditions.
Length: 6000 mm Hydraulic main pumps: 100–140 cc Width: 2000 mm (including axle for transport) Separate filtering and cooling pump Height/transport height: 1800 mm Hydraulic oil tank volume: 120–350 l Netweight: 5000 kg (depends on equipment) Filtration 5μ. Hydraulic oil cooler DRILLING UNIT Heat exchanger Feed Length: 1800 mm Feed Force: 85 kN ELECTRIC MOTOR Pulling Force: 85 kN 55 kW< Max Torque: 800 Nm Drilling Angle: 0–180º WATER PUMP Chuck and rod holder diameter: 37–97 mm High pressure: 100–160 bar Output: 120–165 l/min TRANSMISSION Hydrostatic-mechanical power transmission WIRELINE WINCH Rubber track / wheel based mounted Drum capacity: 300-600 m Drive speed: 0-4 km/h
(Values depend on the configuration)
Arctic Drilling Company Ltd.
Teollisuustie 26B, 96320 Rovaniemi Finland www.adcltd.fi tel +358 40 511 2289, mail@adcltd.fi All Rights Reserved