Professional Documents
Culture Documents
Remove and Install Lift Cylinders (Angle Bulldozer)
Remove and Install Lift Cylinders (Angle Bulldozer)
Remove and Install Lift Cylinders (Angle Bulldozer)
Previous Screen
Welcome: r461mex20
Product: TRACK-TYPE TRACTOR
Model: D4H TRACK-TYPE TRACTOR 8PB
Configuration: D4H & D4H LGP SERIES II TRACTORS / POWER SHIFT /
8PB04000-UP (MACHINE) POWERED BY 3204 ENGINE
Make sure the machine is on level ground. Stop the engine, and move
the control lever to make sure the weight of the bulldozer blade is on the
ground. Move the control lever backward and forward to release the
pressure in the hydraulic system. Slowly loosen the cap to release any
pressure in the hydraulic tank. Let the hydraulic oil become cool before
any lines are disconnected in the hydraulic system.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpa… 1/2
31/1/2018 D4H & D4H LGP SERIES II TRACTORS / POWER SHIFT / 8PB04000-UP (MACHINE) POWERED BY 3204 ENGINE(SEBP1895 - 04) - D…
3. Remove the bolt, retainer (4) and pin (3) from each end of the cylinder. Remove the cylinder from the
machine. The weight of the lift cylinder is 46 kg (101 lb.).
NOTE: The following steps are for installation of the lift cylinder.
4. Fasten a hoist to the cylinder (2). Put the lift cylinder in position, and install pins (3) on each end of the
cylinder.
5. Install retainers (4) and the bolts to hold the pins in position.
Copyright 1993 - 2018 Caterpillar Inc. Wed Jan 31 2018 18:59:20 GMT-0500 (Hora est. Pacífico, Sudamérica)
All Rights Reserved.
r461mex20
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&calledpa… 2/2