2instalaton Gator THeawe « Taeane S00 MEHE (eovem=nN
FACTORY RESET: Choosing this option willreset ll user programmable settings tothe factory default
settings. MMSI will also be reset.
MMS! RESET: Choosing this option will only reset the MMSI number. Input new MMSI number
after power up.
2.13 Factory resetting / MMSI resetting
Factory resetting and MMSI resetting is done on the Control Unit via the options menu.
To enter the options menu press MENU, select SETUP and finally select OPTIONS
‘Then enter the access code 1-2-3-4
Factory resetting
Select FACTORY RESET
‘The Control Unit will prompt for power off of the equipment.
When powered up again the System is in a state as described below.
The Factory Reset puts the System back to the default state originally set atthe factory
‘The chapters 2.10, 2.11 and 2.12 must therefore be repeated in order to restore the System settings
before the Factory Reset,
‘The MMS! number must also be entered
‘The Factory Reset removes configuration keys regarding Telex Operation and 6 ch scanning DSC
Watch Receiver if any of these keys were enabled.
Therefore its necessary to carry out section 2.14 and 2.15, ifthe options have been installed before the
factory reset.
MMSI resetting
Select MMSI RESET
‘The Control Unit will prompt for power oft
When powered up again the System isin a state as described below
The MMSI reset only clears the MMS! number and when the system is powered up again the MMS!
umber us the only parameter which has to be reprogrammed.
Note: The System serial number is not affected by either the Factory Reset or the MMSI reset.
2.14 Enabling the 6 ch scanning DSC Watch Receiver
For the MF/HF product a 6 ch scanning DSC Watch Receiver option is available. The option is enabled
by entering a 10-