Professional Documents
Culture Documents
Project: Bending Brake
Project: Bending Brake
http://www.millerwelds.com/interests/projects/bending-brake/ 03/08/2010
Miller - Projects - Bending Brake Página 2 de 3
• 5/8 inch (1.587 cm) drill bit 10. Weld one 3/4 inch (1.905 cm) nut
to the end of each piece of 10
• Minimum of 4 clamps inch (25.4 cm) x 16ga tubing and
slide the rubber handle over the
• Ruler
other end. If you would like to
make extensions, you can cut
two more pieces of 16ga tubing
to the length you want, weld two
more 3/4 inch (1.905 cm) nuts on
one end and then weld a 3/4 inch
(1.905 cm) bolt to each end of
the handles you made first.
Then, just screw the extensions
on when you need them.
Safety is the primary concern on any project. Always use tools and equipment in
accordance with the manufacturer's instructions. For Miller products, refer to your
Owner's Manual for complete safety precautions and procedures.
Miller provides the information in the "Welding Projects" section of this site for your information only.
You are entirely responsible for your use of the information, your equipment, and the items you
build. You are responsible for any injury to yourself or others and for any property damage. The
information represents the opinions of individual welders, and does not necessarily reflect the
opinions and views of Miller. The projects have not been engineered by Miller. Miller expressly
disclaims any claims related to any content. For further information, see our Terms of Use.
Follow Us:
Home | Products | Where to Buy | Service | Resources | Industry & Interests | About Us
Partner Login | International | Site Help | Privacy Policy | Terms of Use
http://www.millerwelds.com/interests/projects/bending-brake/ 03/08/2010
Miller - Projects - Bending Brake Página 3 de 3
http://www.millerwelds.com/interests/projects/bending-brake/ 03/08/2010