Professional Documents
Culture Documents
Panduit 7 Con 95
Panduit 7 Con 95
Panduit 7 Con 95
127 m
137 m
147 m
2During an office renovation project, a cabler is required to pull four cables into a completed office. Hash marks are used to t
identify the cables. What is the recommended number of markings and how far apart should they be?
two marks 0.5 m (1.5 ft) apart on each end
3 A cabling technician is labeling two Cat5e cables in Mrs. Hill’s room. The classroom number is 116. What is the best labelin
use?
116A and 116B
4What is a disadvantage of tying cables together for long distances in uniform parallel arrays?
It looks messy and unorganized.
Runs may promote the induction of electrons from high voltage lines.
5 What is a cable that is wired T568B on one end, while the other end is wired T568A?
crossover cable
rollover cable
6When designing the demarc space, how many usable square meters must be exceeded before a locked, dedicated, and en
is recommended?
500
1000
2000
4000
7 When using single-mode fiber-optic cable for the backbone, what is the maximum cable length between the HC and the MC
1500 meters
2000 meters
2500 meters
3000 meters
orange
green
brown
9 What is the range of relative humidity that should be maintained in the TR?
10 to 30 percent
30 to 50 percent
50 to 70 percent
70 to 90 percent
predrilled brass
11 What is the minimum gauge of wire that can be used for bonding wires connecting to the TGB?
4 AWG
6 AWG
8 AWG
10 AWG
12The central point for telecommunications grounding in a building is the Telecommunications Main Grounding Busbar (TMG
are the dimensions of the TMGB?
25 mm (1 in.) wide and 3 mm (0.14 in.) thick
TIA/EIA-569-A
TSB-67
TSB-95
green
brown
15 Special cable management systems, called innerducts, are used exclusively for which type of media?
Category 6
Category 5e
ScTP
Fiber-optic
16 What is the maximum number of work areas that can be used for each MUTOA?
6
10
12
20
17What is the proper way to label a phone wall plate located in room 104 of an elementary school where Mrs. Gunnerson tea
fourth grade class?
phone
gunnerson phone
104A
gunnerson 104
18 While working with a senior cable installer, an apprentice is instructed to go into an adjacent room and help complete a pul
the cable labeled WTC116-04. What is the purpose of the pull check?
to test the strength member of the cable
19New cable is being installed in a building. What should be done with the abandoned (old) cable?
Cut off all connections to ensure that the abandoned cable will not be used in the future.
Push the abandoned cable up into the ceiling tile area so that it cannot be seen or used.
Put a "Do not use, old cable" label on all abandoned cables.
21How many square meters must a floor area exceed in order to require more than one TR per floor?
500
750
1000
1500
22 Which cable is wired TIA/EIA-568-A or TIA/EIA-568-B on one end, while the other end is reversed pin for pin?
crossover
rollover
straight through