This document outlines requirements for welder qualification testing according to AWS D1.1/D1.1M:2015 standards. It specifies that tack welds should not be in the test area when radiographic testing is used. It also provides requirements for backing thickness and width depending on whether backing is removed for radiographic testing. For 3/8 inch thick plate, a side-bend test may substitute for each required face- and root-bend test.
This document outlines requirements for welder qualification testing according to AWS D1.1/D1.1M:2015 standards. It specifies that tack welds should not be in the test area when radiographic testing is used. It also provides requirements for backing thickness and width depending on whether backing is removed for radiographic testing. For 3/8 inch thick plate, a side-bend test may substitute for each required face- and root-bend test.
This document outlines requirements for welder qualification testing according to AWS D1.1/D1.1M:2015 standards. It specifies that tack welds should not be in the test area when radiographic testing is used. It also provides requirements for backing thickness and width depending on whether backing is removed for radiographic testing. For 3/8 inch thick plate, a side-bend test may substitute for each required face- and root-bend test.
This document outlines requirements for welder qualification testing according to AWS D1.1/D1.1M:2015 standards. It specifies that tack welds should not be in the test area when radiographic testing is used. It also provides requirements for backing thickness and width depending on whether backing is removed for radiographic testing. For 3/8 inch thick plate, a side-bend test may substitute for each required face- and root-bend test.
a When RT is used, no tack welds shall be in test area.
b The backing thickness shall be 1/4 in [6 mm] min. to 3/8 in [10 mm] max.; backing width shall be 3 in [75 mm] min. when not removed for RT, otherwise 1 in [25 mm] min. c For 3/8 in [10 mm] plate, a side-bend test may be substituted for each of the required face- and root-bend tests.
Figure 4.20—Test Plate for Limited Thickness—All Positions—