Professional Documents
Culture Documents
2012 Volvo A40F: ASC Greenville, NC 252-754-5280
2012 Volvo A40F: ASC Greenville, NC 252-754-5280
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 2 of 15
General Appearance
GENERAL:
Radiator Grille: Good Precleaner bowl: Not Available
Radiator Shroud: Good Fuel Tank: Good
Engine Enclosure: Good Cab Doors: Good
Hood: Good Bumper: Not Available
Stack: Good Cab: Good
Right front fender: Good Steps: Good
Left front fender: Good Grab Irons/Handrails: Good
Rear frame: Good Paint: Good
Front frame: Good Oil Sample Taken: No
LEGEND OF CONDITIONS:
Excellent - New condition. No Repairs Necessary. Poor - Obvious wear and/or damage. Repairs
necessary.
Good - No apparent wear or damage, Not Applicable - Does not apply to this unit
Functions/Operates correctly. No Repairs
Necessary.
Fair - Wear and/or damage apparent. Functions,
but not correctly. Repairs recommended.
NOTES:
.
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 3 of 15
Interior Section
SAFETY ITEMS:
Glass: Good Neutral Start Switch: Good
Mirrors: Good Fire Suppression System: Not Available
Seat Belt: Good Horn: Good
Back Up Alarm: Good
Fan Guards: Not Available
NOTES:
OPERATOR AREA:
Dash Console: Good +Seat Cushion: Fair
Meter: Good Repair Tear In Jump Seat Cushion
Arm Rests: Good
Gauges: Good
Floor Boards/Mats: Good
Control Pattern Decals: Good
EMS Panel: Good
Switches: Good
Warnings: Good
Windshield Wipers: Good
Door Latches: Good
Heater: Good
Current Parts Manual: Yes
A/C: Good
Current Safety Manual: Yes
Interior Lights: Good
Current O&M Manual: Yes
NOTES:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 4 of 15
Power Systems
ENGINE:
Engine Make Model: Volvo D16H Oil Pressure: Normal
Engine S/N: 58580 Smoke: No
Engine Hours: 5957 Smoke Color: Not Applicable
+Oil Leaks: Yes TurboCharger: Good
Valve Cover Gasket - Oil Cooler Area Fuel Injection System: Good
Blow-by: No
Governor: Good
Knocking: No
Engine Supports: Good
Compression in Radiator: No
+Air Cleaners: Fair
Water in Oil: No Replace - Dirty
Fluid Level OK?: Yes
Anit-Freeze Color: Green
NOTES:
COOLING SYSTEM:
Radiator: Good Fan: Good
Coolers: Good Fan Drive: Good
Hoses: Good Belts: Good
Water Pump: Good Pulleys: Good
NOTES:
ELECTRICAL SYSTEM:
Batteries: Good Wiring: Good
Battery Cables: Good Pre-Heater: Good
Starter: Good Lighting: Good
+Alternator: Fair
Repair "Battery Not Charging" Warning
NOTES:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 5 of 15
STEERING:
Steering Linkage: Good Left steering cylinder: Good
Steering Valve: Good Right steering cylinder: Good
Steering Pump: Good Steering joints: Good
+Articulation P & B: Fair
Repair Bushgin - Large Horizontal Gap
NOTES:
BRAKE:
Mechanism: Dry Lines: Good
Type: Pedal Compressor: Not Available
Perfomance: Good Brake linkage: Good
Brake drums: Not Available Master cylinder: Not Available
Rotors: Good Parking brake: Good
Control Valve: Good
NOTES:
DRIVE TRAIN:
Front axle: Good Rear axle housing: Good
Front differential: Good U-Joints: Good
Rear axles: Good Front suspension: Good
Rear differentials: Good Rear suspension: Good
Front wheel lugs & rims: Good Front a-stay: Good
Rear wheel lugs & rims: Good +Rear a-stay: Fair
Front axle bolts: Good Repair Bushing - Chewed Up
Rear axle bolts: Good
Front axle housing: Good
NOTES:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 6 of 15
Hydraulics
HYDRAULICS:
+Right dump cylinder: Fair Valves: Good
Repair Sponge Seal - Out Control linkage: Good
+Left dump cylinder: Fair
Reservoir: Good
Replace Line Clamp
Hose lines: Good Dump cycle test: Good
Pumps: Good
NOTES:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 7 of 15
Dump Body
DUMP BODY:
Body type: N/A +Body pins and bushings: Fair
Body bottom: Good Body Resting On Pads - No Gap
Body liner: Not Available
+Body sides: Fair
Repair Both Top Rails - Cracked +Tail gate adapter: Fair
+Rubber pads: Fair Mount Bolts - Nuts - Spacers Missing
Repair Rear Pads - Chewed Up Tail gate: Fair
Body mounts: Good Front spill guard: Not Available
NOTES:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 8 of 15
Tires
TIRES:
Front Tire Size: Left: 29.5R25 Right: 29.5R25 Rear Tire Size 1: Left: 29.5R25 Right: 29.5R25
Left: Michelin- Right: Michelin- Left: Michelin- Right: Michelin-
Front Tire Brand: Rear Tire Brand 1:
93% 85% 93% 94%
Front Tire Radial or Bias: Left: Radial Right: Radial Rear Tire Radial or Bias: Left: Radial Right: Radial
Front Tire Measurement: Left: 51/32 Right: 47/32 Rear Tire Measurement 1: Left: 51/32 Right: 52/32
Rear Tire Size 2: Left: 29.5R25 Right: 29.5R25
Left: Michelin- Right: Michelin-
Rear Tire Brand 2:
76% 91%
Rear Tire Radial or Bias: Left: Radial Right: Radial
Rear Tire Measurement 2: Left: 42/32 Right: 50/32
NOTES:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 9 of 15
Comments
COMMENTS:
Public Comments:
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 10 of 15
Reconditioning
DEFICIENCY REVIEW:
ITEM QTY PRICE
1. + Replace Missing Bolt On Tail Gate $0.00
2. + Air Filter Dirty $0.00
3. + Alternator Repair, Not Charging Battery $0.00
4. + Left Dump Cylinder, Replace Line Clamp $0.00
5. + BodySides, Repair Both Top Rails, Cracked $0.00
6. + Tail Gate, Repair Missing Bolts, Nuts, Spacers $0.00
7. + Tail Gate, Bent and Dented $0.00
8. + Seat Cushion, Repair Tear in Trainer Seat Cushion $0.00
9. + Repair Seep At Oil Cooler $0.00
Total $0.00
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 11 of 15
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 12 of 15
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 13 of 15
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 14 of 15
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013
LeaseInspector Off-Lease Page 15 of 15
http://leaseinspector.com/Creditor/ViewKAH.asp?SETTAB=CR&PRINT=YES&ASSETI... 6/21/2013