1. find alarm of RXOCF i.e VSVIR or RX diversity lost if present the get re
2. find alarm of TRU if any alarm the get rectified
3. use command RLCRP:CELL=cell; and in output see the ICM band mu
to 3if
ICM band is 4-5 then correspond TRU is faulty get replacement (for finding th
corresponding TRU use BPC no. in RLCRP: CELL=cell; and RXCDP: MO=RXOT(
4. check handover report form Network quality report that is handover is
properly work
5. define handover if not present in neighbor list using the command
RLNRP: CELL=cell, CELLR=al ( for neighbor list)
RLNRI: CELL=cell, CELLR=cellr; (for cellr add in neightsctify it
ist bel
e
Stas)
dor list)1. Find that site working in full configuration by using comman¢
RXCDP: MO=RXOTG-tg$; (ALL mo must be con
If any BLOCKED found then use command
RXASP: MO=RXOTG-tg$; (to find the all alarm and reason of
IF LOCAL MODE found than try to make REMOTE otherwise
Check the fault code by command
RXMFP:MO=m0osS; (to find the exact fault code to make decis
hardware if faulty or not if hardware is faulty and need replai
book the fault to ericsson and if the hardware is not faulty th
BLOCK/DEBLOCK to make unit operational )
If any mo not block then check the half rate is on or o
For checking half rate use command
RLDHP: CELL=cell; (DHA=ON)
If DHA not ON use command to on it
RLDHC: CELL=cell, DHA=ON;
If traffic is more than for witch site is configured (as erlang
increase the value of half rate by using command
RLDHC: CELL=cell, DTHAMR=100, DTHNAMR=100;
Erlang B table
TRU (Per sector) Traffic that supported on full rate
2.2E
8.0E
14.5E
21.4E
28.5E
35.8E
43.1E
50.5E
If none of the above case so new BTS is required to releas:
ONYOUAWNE