Pressure dependent valves
Pressure switch, barbed fittings for 3 mm plastic tubing
Adjustable pneumatic
pressure switch
‘Type VD-3-PK-3
with 2n sub-base
‘This valve is used when a pressure-de-
pendent signal is required for further
switching of a control circult e.g. when a
minimum clamping pressure of a cylin-
der is reached.
‘The pressure can be set by means of the
adjusting scrow.
When this is done, then, as soon as the
pilot signal at port Z reaches the preset
pressure, the attached 3/2-way valve is
‘actuated. Conversely, the valve switches
back when the signal at Z falls below the
preset pressure.
Mounting frame for manifold mounting
and. control cabinet fitting, see sheet
6.430.
+
t
feo" 68.
1B Secor es a Hi
|_-e-000-ee | !!
|
¥
Lemeao
Barbed tinge tS am paste tubing
@tscning
Pressoreachetng soraw (} sub-division » approx. 1 bar)
1) = Supply por
2 (a) = Wontng a ett no
2 (= Bat
42 @) = Conroe
‘Ordar code Part NoFiype [S270 VO-SPRS
Medium ‘Compressed at, filtered (ubricated or uniubriatad)
Design Poppet valve with return spring
Mounting, “Through-holes in sub-base, or on mounting fame
‘Connection Barbed fitings for 3 mm plastic tubing
‘Nominal si8 25 mm
‘Standard norinal ow rate (PA) "00 min
(Operating pressure range. 1.80 8 bar
‘Adjustable plot pressure to 8 bar
‘Accuracy of _Switch-on pressures > 1 bar | 2%
repetiion __~Swiicr-of pressures >1bar_ | 21.5%
3501 hysteresis at 6 bar bar
“Temperature range = 1010 +60°S
ators
(Weight
Tlousing: ais-cast zine aluminium pressure acluator: aluminium adjusting screw
steel seals: perbunan
(0.220 ig
subeotto change
2.710