Professional Documents
Culture Documents
Y2000 Quad 5 Band
Y2000 Quad 5 Band
This product is designed to prevent cellular communication by blocking the link between the
cell phone and the local cell base station.
SPECIFICATION
Y2000Q5
SPECIFICATION Block System
(4 Patch Antennas Type)
1. Antenna attachment
Before using the jammer you must attach the antenna, failure to do so will cause serious
damage to the jammer and will invalidate the product warranty.
There are 4 x patch antenna (2 long, 2 short) supplied with this product, each antenna
comes with 1 metre of connecting cable. All 4 antenna must be connected to the rear of the
Y2000 unit. For best results the antenna should be placed 1 metre away from each other
and must all face in the same direction towards the target to be jammed. Please see the
table below and also the rear view diagram in this manual for antenna installation.
For Nextel/NMT/AMPS/CDMA/TDMA800 Long Patch Antenna(800)
(SW800PEP)
For 3G (UMTS/CDMA2000) Short Patch Antenna
(SW1R9PEP)
For GSM900 Long Patch Antenna(900)
(SW910PEP)
For GSM1800/ PCS1900/W-CDMA Short Patch Antenna
(SW1R9PEP)
All cell phones within effective range will now lose their network service until such time that
the jammer is switched off.
3. Product Installation
- There are 6 levels of power adjustment for each RF power control on rear of case.
- The product was shipped already set to maximum power.
- If you want lower output, please turn each RF power control to the left
- If you want higher output, please turn each RF power control to the right
- Please handle carefully when you are doing the power adjustment and do not over
adjust in either the min or max settings as this could damage the unit..