Professional Documents
Culture Documents
Calculation: Notes To Remember
Calculation: Notes To Remember
Calculation: Notes To Remember
Calculate the ultimate resistance of soil ( R ) using the formula given below.
R = (w * h) / d
Where,
If “A” is the cross-sectional area of the solid steel ball or cube, then resistance of soil per unit area is
calculated using following formula.
Where,
NOTES TO REMEMBER
1. F.O.S varies from 2 to 3 depending upon the type of structure and site condition.
2. In order to get reliable test result, perform this test on different types of soil and then use your
judgment to reach at any conclusion.
3. Instead of using solid steel ball or square cube, we can also use CBR test plunger, or Cone
(used for cone penetration test)
PRESUMPTIVE BEARING CAPACITY
The table given below shows the presumptive bearing capacity values for different types of soils.
This table will guide you to reach at any conclusion after conducting the test.
Rock 32.40
NOTES TO REMEMBER
1. For non-cohesive soils the values should be reduced by 50% if the water table is above or near
base of footing.
2. These values should be used only for preliminary design. The actual bearing capacity of soil
should be calculated as per the standard codes.