Professional Documents
Culture Documents
EP Series Operation Guide - V1.3 Cannon
EP Series Operation Guide - V1.3 Cannon
EP Series Operation Guide - V1.3 Cannon
Select [Password] Input password Input password again Press [OK] to save
Enroll Card:
Enroll Enroll Card Enroll Card
Enroll Card
FP 1/2
press [OK] Password/ Card [OK] Swipe card! 008101-C
Esc-C Set-OK Cancel-C Sav-OK
2 Admin Setup: Admin(Administrator) has full access permissions to the device. It is recommended to assign a minimum of Place finger straight and
two administrators to each unit. flat on the sensor. Insure
MENU User ▼ Admin Setup Admin Setup Admin Setup Admin Setup maximum sensor coverage.
User Group Setup ID 008101
[OK] [OK] [OK] [OK] [OK]
Setup Admin Setup ID 000000 008101
USB Flash Admin Clear Esc-C Add-OK No-C Yes-OK Esc-C Add-OK
Place finger in the center of the sensor. Place finger on the sensor surface
Select [User] Selelct [Admin Setup] Input Admin ID Setup successful
VF30/VP30 POE Professional Access Control V1.7
IN IN
12I
14:03 09 14:03 09
10-29-09 THU 10-29-09 THU
or 12V COM
D/S GND
Relay State
GND D/M
C
,
ar
d
COM NO
Installation Diagram
NC
2 1 Installation Step Access Control Reader & Access Control Power Supply
+12
12I
12V COM
D/S GND
Exit Button
GND PUSH NO
2 Install and fix back panel, connect related cables
Relay State
Access Control Power Supply
+
Door Sensor
Door Bell
3 4 Attach access control reader
GND
Power on to unlock
NC
Power off to unlock
+
Wiring Instruction
NC
Access Control Reader & Switching Power Supply
P1 PIN Mark Description
+12V GND
D/S GND
3 GND GND Exit Button
Wiegand Switch
5 R4B RS485B
NC
GND GND
D/S GND
2
Power off to unlock
3 D/S Door Switch
GND D/M
6 NO NO
7 COM COM
NC
8 NC NC
Relay State:
RS485 Switch
COM 12V
12V
6 NO
P2 Relay 7 COM
Select either
UP Connect multiple RS485 8
D/S GND
NC
+12V GND
12 volt out on I II III
RELAY DELAY
ON OFF
PROGRAM
POWER
SUPPLY LOCK
12V-O
6 NO(DC12V) NORMAL MODE - (BLUE)
free contact.
ANVIZ DEVICE
P2 Relay 7 COM GND GND
8 NC(DC12V) GND D0
RELAY OUT
NO GND
BUTTON
EXIT
COM BUT
NC
Important notice: Please follow the wiring diagram as it is displayed. Damaged products due to
Exit Button
improper wiring are not covered by product warranty. Power on to unlock