Basing Anestesi

You might also like

Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 1

TerjemahanMatikan terjemahan instan

1473/5000
GENERAL ANASTESION STEPS
1. After the patient is laid on the operating table. Attach tension, saturation, precordial. Turn on
the monitor. Turn on the anesthesia machine. Set the speed of infusion.
2. Wait for instructions. After reporting to the consul, and the operator is ready. Means
anesthesia is allowed.
3. Ask the patient to pray
4. Inject pre medication: SA 0.25 mg and Pethidin 30-50 mg
5. Inject 100 mg Recofol.
Wait until the eyelash reflex is gone.
7. When the eyelash reflex has been lost the mask pairs with the correct position. (Jaw thrust,
chin lift, press mask with thumb and forefinger)
8. Raise oxygen to 6-10 l
9. reduce oxygen to 3 L. increase N2O to 3L. open isofluran / halotan
10. Stay in that position. While sometimes pumping when needed. Note the infusion, pulse,
tension, saturation, pump or machine monitor. Occasional patient's pulse.
11. If the patient is rileks then give Succinil cholin or tramus depending on the required dosage.
12. Furthermore live art anesthesia. If the tension up and down, if the pulse up or down, if breath
is less spontaneous, slow or fast. What we do can deepen or reduce anesthetic drugs, add certain
medications, set the fluid, set the patient's position and others.
13. When the operation is almost finished reduce the dose slowly until then stay oxygen only.
14. The operation is complete ... take the patient to the inpatient room. And wait until the patient
wakes up.

You might also like