Professional Documents
Culture Documents
Installation of ST Series Automatic Transfer Switch
Installation of ST Series Automatic Transfer Switch
This manual serves to assist in the installation of the 200Amp Automatic Transfer Switch (ATS)
used in conjunction with the generator purchased. Electrical wiring is dangerous and if worked
on in the improper fashion could lead to serious bodily injury or even death. It is highly recom-
mended that capable and trained personnel be utilized.
INSTRUCTIONS
1. Mount the transfer switch. Most place the box next to their service panel.
2. Set the switch to the O position. Do this before installing any wiring. Use
the provided manual switching handle to set the switch to the O position
between I and II.
NOTE: Take care as to run the matching G1 and G2 lines from the generator
to the switch as it is critical to the proper AUTO switching of the generator.
In the event you have trouble with the automatic switching of your gen set to
gen power, physically swap the G1 and G2 lines.
4. Attach your L1( Mains L1) and L2(Mains L2) lines from your service to the
TOP FRONT of your transfer switch.
Note: You may have to add your own three way neutral splitter as it is not
provided with the transfer switch.
8. Use the grounding post to ground the box and ground connections. Note:
You may have to provide your own three way grounding terminal. This will
be determined and is at the discretion of the electrician.
10. With the transfer switch wired in, merely set your generator to AUTO mode by press-
ing the AUTO button on your Deep Sea 7220 Controller. When the switch is on Mains
power the lever will indicate the I position as show below.
IF TRY
Mains Fail and Gen Starts but no transfer Physically swapping G1 and G2 Lines
Mains Fail and Gen no start no transfer Check fuse in switch
Mains Resume and Gen no stop no transfer Check fuse in switch