Professional Documents
Culture Documents
Acet
Acet
SIMPLY
SUPPORTED
BEAM
DRAWING NO 1.
Q1. A simply supported beam of effective span
5m simply rest on the wall at its end the size
of the beam is 300mmx500mm the thickness of the
wall is 500mm and the bearing of the beam on
the wall is 300mm on both the sides it is
reinforced with 5-25mm dia bar on tension side
and two 20mm dia bar on its compresion side 2
legged stirrup is provided at centre to centre
draw the plan and cross section of the beam.
LAP
JOINTS
PAN HEAD AND SNAP HEAD
SINGLE RIVETED
DOUBLE RIVETED
DRAWING NO 2.
Q2 a). Draw the sectional view of snap head and
pan head
DRAWING NO 2.
Q2 b). Draw the plan and sectional view of
single riveted lap joint,having thickness 10mm
of both plates.
DRAWING NO 2.
Q2 c). Draw the sectional front view and top
view double riveted lap joint whose thickness
of plate is 10 mm.
BUTT
JOINTS
SINGLE RIVETED
SINGLE COVER
DOUBLE COVER
DOUBLE RIVETED
SINGLE COVER
DOUBLE COVER
DRAWING NO 3.
Q3 a). Draw the plan and sectional view of
single riveted single cover butt joint having
thickness 20mm.
DRAWING NO 3.
Q3 b). Draw the plan and sectional view of
double cover butt joint with single rivet
having plate thickness 20mm.
DRAWING NO 3.
Q3 c). Draw the plan and sectional view of
single cover butt joint with double riveted
having thickness of plate 10mm and cover
plate thickness 5mm .
DRAWING NO 3.
Q3 d). Draw the plan and sectional view of
double cover butt joint with double riveted
having thickness of plate 10mm
and cover plate thickness 5mm .
SLABS
DRAWING NO – 4
Q4. Draw a simply supported R.C.C slab
resting on masonary wall having clear span 6m
WELDED
JOINTS
BUTT WELD
FILLET WELD
DRAWING NO – 5
Q5 a). Draw a plan and sectional view of butt
weld.
DRAWING NO – 5
Q5 b). Draw a plan and sectional view of
fillet weld.
NUT AND
BOLT
DRAWING NO – 6
Q6. Draw a nut and bolted connection.
TENSION
MEMBER
LUG ANGLES
DRAWING NO – 7
Q7. Draw a elevation of a diagonal member of
a roof truss with 16 mm thick gusset plate
using main angle 150x75x10 lug angle
150x75x8.Grade of steel is fe 410 and 20 mm
diameter bolts of grade 4.6.
COMPRESSION
MEMBER
LACING
BATTENING
SPLICING
DRAWING NO – 8
Q8 a). Design the built up section when two
channels are connected back to back .The
channel is ISMC 300@351.2 N/m.
DRAWING NO – 8
Q8 b). Draw the battening plate which connects
two channel section ISMC 350@413N/m.
DRAWING NO – 8
Q8 c). Draw for splicing in which two plates
connects the section ISHB 300@618N/m.