Menz, Martin W. 2012. The Use-Life and Times of the Type-G Shell Hammer: A Descriptive and Experimental Analysis of Shell Hammers from Roberts Island (8CI41). Honors thesis, Department of Anthropology, University of South Florida, Tampa.
paragraph 01 What is backscatter & what is the size of letter B? 02 Where to put the letter B? 03 What if the image of B comes as black and what if the image comes as white? 04 System of identification: what are the IDs that should be on the radiograph as permanent, either as image or by permanent marking? 05 What marking should appear as radiographic images? 06 How you verify the source size? 07 How you select IQI? 08 How you determine sensitivity? 09 Do you add reinforcement for sensitivity calculation? Single side or both sides? 10 What are the density limitations for a radiograph for X- Ray and Gamma Ray? 11 What are the permissible limits of density variations and how you determine it? 12 What are the techniques for radiography? 13 How many minimum IQIs required for a SWSI panoramic exposure? 14 How many exposures required for a DWDI elliptical technique? 15 How many exposures required for a DWDI superimpose technique? 16 What is the maximum interval of densitometer calibration? Does it need to be documented? 17 How you calibrate a densitometer with density strip? 18 What are the minimum steps required to be verified for calibration? 19 What is the frequency of periodic verification of densitometer? Does it need to be documented? 20 How much variation of density between density strip and densitometer reading is acceptable? 20 IQI to be placed at which side? Source side or film side? For SWSI For DWSI For DWDI 21 What is the Ug requirement as per Sec VIII Div. 1? 22 What is the Ug requirement as per Sec I? 23 What are a rounded indication and a linear indication? 24 Which appendix of Sec VIII Div 1 tells about rounded indication acceptance criteria? 25 Which paragraph of Sec VIII Div 1 tells about Radiography acceptance criteria? 26 What are the acceptance criteria for elongated indications as per Sec VIII Div 1? 27 What is the maximum size of a rounded indication? 28 What is the acceptance criterion for rounded indication for spot radiography? 29 What is the acceptance criterion for elongated indication for spot radiography?
Menz, Martin W. 2012. The Use-Life and Times of the Type-G Shell Hammer: A Descriptive and Experimental Analysis of Shell Hammers from Roberts Island (8CI41). Honors thesis, Department of Anthropology, University of South Florida, Tampa.