Professional Documents
Culture Documents
EN Iso 965-1 Addendum
EN Iso 965-1 Addendum
EN Iso 965-1 Addendum
TECHNICAL CORRIGENDUM 1
Published 2009-07-15
INTERNATIONAL ORGANIZATION FOR STANDARDIZATION • МЕЖДУНАРОДНАЯ ОРГАНИЗАЦИЯ ПО СТАНДАРТИЗАЦИИ • ORGANISATION INTERNATIONALE DE NORMALISATION
RECTIFICATIF TECHNIQUE 1
Technical Corrigendum 1 to ISO 965-1:1998 was prepared by Technical Committee ISO/TC 1, Screw threads.
Page 1, Scope
This part of ISO 965 specifies a tolerance system for ISO general purpose metric screw threads (M)
conforming to ISO 261.
Published in Switzerland
Copyright International Organization for Standardization
Provided by IHS under license with ISO Sold to:JOE PREMO, W1072596
No reproduction or networking permitted without license from IHS Not for Resale,2011/3/15 17:51:35 GMT
ISO 965-1:1998/Cor.1:2009(E)
Replace the references to ISO 965-2 and ISO 5408 with the following:
ISO 965-2, ISO general purpose metric screw threads — Tolerances — Part 2: Limits of sizes for
general purpose external and internal screw threads — Medium quality
Page 2, 3.2
In the first column of the table, 15th row, replace Td1 with Td.
Page 4, 5.2
In the first paragraph, second line, replace “according to” with “in accordance with”.
Page 18
Add the following bibliography at the end of the document after 13.4.2:
Bibliography
[1] ISO 898-1, Mechanical properties of fasteners made of carbon steel and alloy steel — Part 1:
Bolts, screws and studs with specified property classes — Coarse thread and fine pitch thread
--`,,,,,`,```,```,`,`,,-`-`,,`,,`,`,,`---
2
Copyright International Organization for Standardization © ISO 2009 – All rights reserved
Provided by IHS under license with ISO Sold to:JOE PREMO, W1072596
No reproduction or networking permitted without license from IHS Not for Resale,2011/3/15 17:51:35 GMT