Professional Documents
Culture Documents
Flashcards 34
Flashcards 34
bandwidth?
What guideline should not be used when developing tests Evaluations are norm-referenced
and evaluations for your training program?
What is incorrect when posting a “Danger” Tag? The signal word should be readable at a minimum distance of
7 feet or greater
What is correct concerning the conference training method? The success of the conference depends almost entirely on the
ability of the facilitator
Peter F. Drucker’s definition of productivity? The balance between all factors of production that will give
the greatest output for the smallest effort
What would have the lowest value? Threshold Limit Value? (TLV)
When Halon 1301 is exposed to high temperature (over 900 Hydrogen fluoride
degrees Fahrenheit) hydrogen based fire which of the
following gases is formed?
What is not true concerning flammable inside storage areas? Normally limited to 600 gallons-not true
What would indicate seepage thru the core wall on the Exposed gravel showing on the downstream slope
downstream side of an earthen impounding reservoir water
collection dam or berm?
What detector is best suited for large open areas? Photoelectric
What is true concerning placement of structural reinforcing Steel should be placed low
steel in concrete beams that are supported on either end?
(assume no support in the middle of the span)
When using mobile cranes the radius of a pick is always Center of rotation after boom deflects under load
measured from the center of the load to what point on the
crane?
What is not true concerning the GFCI? It will not detect line-to-line faults
What describes a violent reaction that occurs when two Hypergolic
materials come into contact with each other?
In completing a Product Safety Failure Modes and Effects Other products in the same category
Analysis (FMEA) the safety professional should not include
which of the following?
In comparison to the process of Fault Tree analysis, the failure More time
modes and effects analysis requires??
Line up in the correct order from most time consuming to ETA, FMEA and FTA
least time consuming the system safety analysis?