Professional Documents
Culture Documents
#86485 Jewelers Miter Jig Instructions For Use: Thumb Nuts
#86485 Jewelers Miter Jig Instructions For Use: Thumb Nuts
Loosen the
THUMB NUTS thumb nuts to
open the jaws.
Insert your
workpiece into
a suitable
groove to hold
“FLAT FENCE” it at the needed
angle. Then,
45˚ JAWS
gently tighten
the thumb nuts
90˚ JAWS until the
workpiece is
securely held
SET SCREW without being
FOR STOP BAR (2) crushed.
Note: Flat stock
STOP BAR should be
placed against
HEX KEY FOR the flat fence to
SET SCREWS hold it “square”
to the jaws.
Lay your saw blade up against the surface of the jaws to guide the cut. After
the cut is made, run your file across the surface to smooth out the cut and
finish to size.
www.micromark.com
MM020416