Professional Documents
Culture Documents
Eu Regulations PDF
Eu Regulations PDF
EUROPEAN COMMISSION
HEALTH & CONSUMERS DIRECTORATE-GENERAL
File:INT/REF_LEG+Compend
(14/02/2011)
Working document
(Updated version December 2011)
Introduction
In Part I and II of this document, relevant references of the EU Directives and Regulations are
mentioned. As regards the EU Directives you can find, in general, the references and the texts
on the “EUR-LEX” website http://eur-lex.europa.eu. On this website you can also find
information on where and how you can purchase the Official Journal of the European Union.
An overview of Sales Agents is also given in Part IV.
Part III is a compendium of national legislation on food contact materials and articles. This
document does not claim to be a complete compilation. It is based on information provided by
Member States to the Commission Services. Per Member State, the date of last update is
mentioned.
In the email addresses, the symbol "@" is replaced by "(a)" in order to avoid spam.
TABLE OF CONTENTS
INTRODUCTION ............................................................................................................................................................ 1
(EC) No 1895/2005................................................................................................................................................... 12
Repealed: .................................................................................................................................................................. 12
2004/13/EC ............................................................................................................................................................................12
2002/16/EC ............................................................................................................................................................................12
2001/61/EC ............................................................................................................................................................................12
ELASTOMERS AND RUBBERS .......................................................................................................................................... 13
93/11/EEC ................................................................................................................................................................ 13
ACTIVE AND INTELLIGENT MATERIALS AND ARTICLES ................................................................................................. 13
(EC) No 450/2009..................................................................................................................................................... 13
PART II: OTHER EU DIRECTIVES AND REGULATIONS RELATED TO FOOD CONTACT MATERIALS
.......................................................................................................................................................................................... 14
FOODSTUFFS AND FOOD CONTACT MATERIALS: CONTROL ........................................................................................... 14
(EC) No 882/2004..................................................................................................................................................... 14
TIN IN CANNED FOODSTUFFS ......................................................................................................................................... 14
(EC) No 1881/2006................................................................................................................................................... 14
TIN IN CANNED FOODSTUFFS: CONTROL ........................................................................................................................ 14
(EC) No 333/2007..................................................................................................................................................... 14
GENERAL FOOD LAW .................................................................................................................................................... 14
(EC) No 178/2002..................................................................................................................................................... 14
HYGIENE OF FOODSTUFFS .............................................................................................................................................. 14
(EC) No 852/2004..................................................................................................................................................... 14
MARKETING AND USE OF CERTAIN DANGEROUS SUBSTANCES AND PREPARATIONS ....................................................... 15
76/769/EEC .............................................................................................................................................................. 15
Marketing and use of certain dangerous substances and preparations: perfluorooctane sulfonates: 2006/122/EC...............15
Marketing and use of certain dangerous substances and preparations: Phtalates in toys and childcare articles 2005/84/EC 15
Marketing and use of certain dangerous substances and preparations: tin, PCP and cadmium: 1999/51/EC ........................15
PART III: REFERENCES OF NATIONAL LEGISLATION................................................................................... 16
Part III:...................................................................................................................................................................................17
COMPENDIUM OF NATIONAL LEGISLATION ON FOOD CONTACT MATERIALS AND ARTICLES...................17
AUSTRIA..................................................................................................................................................................... 18
BELGIUM.................................................................................................................................................................... 20
BULGARIA ................................................................................................................................................................. 21
CYPRUS....................................................................................................................................................................... 23
CZECH REPUBLIC ..................................................................................................................................................... 25
DENMARK .................................................................................................................................................................. 27
ESTONIA ..................................................................................................................................................................... 28
FINLAND..................................................................................................................................................................... 29
FRANCE ...................................................................................................................................................................... 30
GERMANY .................................................................................................................................................................. 33
GREECE....................................................................................................................................................................... 35
HUNGARY .................................................................................................................................................................. 38
IRELAND..................................................................................................................................................................... 40
ITALY .......................................................................................................................................................................... 41
LATVIA ....................................................................................................................................................................... 47
LITHUANIA ................................................................................................................................................................ 48
LUXEMBOURG .......................................................................................................................................................... 49
MALTA........................................................................................................................................................................ 50
THE NETHERLANDS................................................................................................................................................. 51
NORWAY .................................................................................................................................................................... 54
POLAND...................................................................................................................................................................... 55
PORTUGAL................................................................................................................................................................. 57
ROMANIA ................................................................................................................................................................... 59
SLOVAKIA.................................................................................................................................................................. 62
SLOVENIA .................................................................................................................................................................. 64
SPAIN........................................................................................................................................................................... 65
SWEDEN ..................................................................................................................................................................... 67
UNITED KINGDOM ................................................................................................................................................... 68
PART IV: SALES AGENTS ......................................................................................................................................... 70
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
Part I: EUROPEAN DIRECTIVES AND REGULATIONS 4 of 71
Overview of EU legislation (valid until 1 May 2011)
As of 1 May the legislation in the left red single frame will be repealed or consolidated by (EU) No 10/2011
As of 1 January 2013 the rules provided by the legislations in the right green double frame will be replaced by the provisions on migration testing and simulants in (EU) No
(EC) No 1935/2004
10/2011. Framework
2023/2006/EC
Good Manufacturing
practice
(applicable to all Food
Contact Materials)
2005/79/EC 97/48/EC
3rd amendment 2nd amendment
2007/19/EC
4th amendment
2008/39/EC
5th amendment
(EC) No 975/2009
6th amendment
2011/8/EU
BPA measure
7th amendment
Paper and Board Glass Wood Cork Metals and alloys Textiles Adhesives Printing inks Waxes
Ion-exchange resins Silicones Varnishes and
coatings
5 of 71
(EC) No 1935/2004
Framework
Regulation
2023/2006/EC
Good Manufacturing
practice
(applicable to all Food
Contact Materials)
93/8/EEC 85/572/EC
1st amendment List of simulants
(EU) No 321/2011
Bisphenol A
1st amendment 97/48/EC
2nd amendment
(EU) No 1282/2011
2nd amendment
Paper and Board Glass Wood Cork Metals and alloys Textiles Adhesives Printing inks Waxes
Ion-exchange resins Silicones Varnishes and
coatings
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any liability for its content.
6 of 71
Framework Regulation
(EC) No 1935/2004
Regulation of the European Parliament and of the Council of 27 October 2004 on materials
and articles intended to come into contact with food and repealing Directives 80/590/EEC and
89/109/EEC
O.J. L338 of 13.11.2004, p.4
(Framework Regulation)
Repealed:
89/109/EEC
Council Directive of 21 December 1988 on the approximation of the laws of the Member
States relating to materials and articles intended to come into contact with foodstuffs.
O.J. L40, of 11.02.1989, p.38
Corrigendum O.J. N° L347 of 28.11.89, p.37
(Framework Directive repealed by Framework Regulation 1935/2004)
80/590/EEC
Commission Directive of 9 June 1980 determining the symbol that may accompany materials
and articles intended to come into contact with foodstuffs.
O.J. L151, of 19.06.1980, p.21
(Symbol for materials and articles, repealed by Framework Regulation (EC) No 1935/2004)
76/893/EEC
Council Directive of 23 November 1976 on the approximation of the laws of the Member
States relating to materials and articles intended to come into contact with foodstuffs.
O.J. L340, of 09.12.1976
(Old framework directive, repealed by Directive 89/109/EE)
Repealed:
2004/14/EC
Commission Directive of 29 January 2004 amending Directive 93/10/EEC relating to
materials and articles made of regenerated cellulose film intended to come into contact with
foodstuffs
O.J. L27 of 30.01.2004, p.48
(Regenerated Cellulose : 2nd amendment to Directive 93/10/EEC, repealed by 2007/42/EC)
93/111/EEC
Commission Directive of 10 December 1993, amending Directive 93/10/EEC relating to
materials and articles made of regenerated cellulose film intended to come into contact with
foodstuffs.
7 of 71
93/10/EEC
Commission Directive of 15 March 1993 relating to materials and articles made of
regenerated cellulose film intended to come into contact with foodstuffs
O.J. L93, of 17.4.93, p.27
(Regenerated Cellulose: Codification of 83/229/EEC, repealed by 2007/42/EC)
92/15/EEC
Commission Directive of 11 March 1992, amending Council Directive 83/229/EEC on the
approximation of the laws of the Member States relating to materials and articles made of
regenerated cellulose film intended to come into contact with foodstuffs.
O.J. L102, of 16.04.1992, p.44
(Cellulose regenerated: 2nd Amendment, repealed by Directive 93/10/EEC)
86/388/EEC
Commission Directive of 23 July 1986, amending Council Directive 83/229/EEC on the
approximation of the laws of the Member States relating to materials and articles made of
regenerated cellulose film intended to come into contact with foodstuffs.
O.J. L228, of 14.08.1986, p.32
(Regenerated Cellulose: 1st Amendment, repealed by Directive 93/10/EEC)
83/229/EEC
Council Directive of 25 April 1983 on the approximation of the laws of the Member States
relating to materials and articles made of regenerated cellulose film intended to come into
contact with foodstuffs.
O.J. L123, of 11.05.1983, p.31
(Regenerated Cellulose, repealed by Directive 93/10/EEC)
Ceramics
2005/31/EC
Commission Directive of 29 April 2005 amending Council Directive 84/500/EEC as regards a
declaration of compliance and performance criteria of the analytical method for ceramic
articles intended to come into contact with foodstuffs
O.J. L110, of 30.04.2005, p.36
(Ceramics – 1st amendment)
84/500/EEC
Council Directive of 15 October 1984 on the approximation of the laws of the Member States
relating to ceramic articles intended to come into contact with foodstuffs.
O.J. L277, of 20.10.1984, p.12
(Ceramics)
Plastics materials
(EU) No 1282/2011
Commission Regulation of 28 November 2011 amending and correcting Commission Regulation
(EU) No 10/2011 on plastic materials and articles intended to come into contact with food.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
8 of 71
(EU) No 321/2011
Commission Implementing Regulation of 1 April 2011 amending Regulation (EU) No 10/2011 as
regards the restriction of use of Bisphenol A in plastic infant feeding bottles
O.J. L87, of 02.04.2011, p.1
(Plastics: 1st amendment to (EU) No 10/2011)
(EU) No 10/2011
Commission Regulation of 14 January 2011 on plastic materials and articles intended to come into
contact with food.
O.J. L12, of 15.01.2011, p.1
(Plastics: applicable as of 01/05/2011 and repealing the Plastics Directives 2002/72/EC, and
consolidating the Directives on vinyl chloride and the Directives on migration testing and the list of
simulants – all mentioned as repealed or consolidated here below)
2011/8/EU
Commission Decision of 28 January 2011 amending Directive 2002/72/EC as regards the
restriction of use of Bisphenol A in plastic infant feeding bottles
O.J. L6, of 11.01.2011, p.15
(Plastics: 7th amendment to Directive 2002/72/EC, repealed by Regulation (EU) No 10/2011 as of
01/05/2011)
(EC) No 975/2009
(EC) No 975/2009 Commission Regulation of 19 October 2009 amending Directive 2002/72/EC
relating to plastic materials and articles intended to come into contact with foodstuffs
O.J. L274, of 20.10.2009, p.3
(Plastics: 6th amendment to Directive 2002/72/EC, repealed by Regulation (EU) No 10/2011 as of
01/05/2011)
2008/39/EC
Commission Directive of 6 March 2008 amending Directive 2002/72/EC relating to plastic
materials and articles intended to come into contact with food
O.J. L63, of 07.03.2008, p.6
(Plastics: 5th amendment to Directive 2002/72/EC, repealed by Regulation (EU) No 10/2011 as of
01/05/2011)
Corrigendum to 2007/19/EC
Corrigendum to Commission Directive of 2 April 2007 amending Directive 2002/72/EC relating to
plastic materials and articles intended to come into contact with food and Council Directive
85/572/EEC laying down the list of simulants to be used for testing migration of constituents of
plastic materials and articles intended to come into contact with foodstuffs.
O.J. L97, of 12.04.2007, p.50
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
9 of 71
2004/19/EC
Commission Directive of 01 March 2004 amending Directive 2002/72/EC 2002 relating to
plastic materials and articles intended to come into contact with foodstuffs
O.J. L71, of 10.03.2004, p.8
(Plastics: 2nd amendment to Directive 2002/72/EC, repealed by Regulation (EU) No 10/2011 as of
01/05/2011)
2004/1/EC
Commission Directive of 6 January 2004 amending Directive 2002/72/EC as regards the
suspension of the use of azodicarbonamide as blowing agent
O.J. L7, of 13.01.2004, p.45
(Plastics: first amendment to Directive 2002/72/EC, repealed by Regulation (EU) No 10/2011 as of
01/05/2011)
Corrigendum to 2002/72/EC
Corrigendum to Commission Directive 2002/72/EC of 6 August 2002 relating to plastic
materials and articles intended to come into contact with foodstuffs.
O.J. L39, of 13.02.2003, p.1
(Plastics: Codification of 90/128/EEC + 7 amendments, repealed by Regulation (EU) No 10/2011
as of 01/05/2011)
2002/72/EC
Commission Directive of 6 August 2002 relating to plastics materials and articles intended to
come into contact with foodstuffs.
O.J. L220, of 15.08.2002, p.18
(Plastics: Codification of 90/128/EEC + 7 amendments, repealed by Regulation (EU) No 10/2011
as of 01/05/2011)
Vinyl Chloride
81/432/EEC
Commission Directive of 29 April 1981 laying down the Community method of analysis for
the official control of vinyl chloride released by materials and articles into foodstuffs.
O.J. L167, of 24.06.1981, p.6
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
10 of 71
80/766/EEC
Commission Directive of 8 July 1980 laying down the Community method of analysis for the
official control of the vinyl chloride monomer level in materials and articles which are
intended to come into contact with foodstuffs.
O.J. L213, of 16.08.1980, p.42
(Plastics: Determination of VCM in finished products, consolidated by Regulation (EU)
No 10/2011 as of 01/05/2011)
Migration Testing
97/48/EC
Commission Directive of 29 July 1997 amending for second time Council Directive
82/711/EEC laying down the basic rules necessary for testing migration of the constituents of
plastics materials and articles intended to come into contact with foodstuffs
O.J. L222, of 12.8.97, p 10
(Plastics: Basic rules for testing migration - 2nd amendment, consolidated by the rules in
Regulation (EU) No 10/2011 as of 01/01/2013)
93/8/EEC
Commission Directive of 15 March 1993 amending Council Directive 82/711/EEC laying
down the basic rules necessary for testing migration of the constituents of plastics materials
and articles intended to come into contact with foodstuffs
O.J. L90, of 14.4.93, p.22
(Plastics: Basic rules for testing migration - 1st amendment, consolidated by the rules in
Regulation (EU) No 10/2011 as of 01/01/2013)
82/711/EEC
Council Directive of 18 October 1982 laying down the basic rules necessary for testing
migration of the constituents of plastic materials and articles intended to come into contact
with foodstuffs.
O.J. L297, of 23.10.1982, p.26
(Plastics: Basic rules for testing migration, consolidated by the rules in Regulation (EU)
No 10/2011 as of 01/01/2013)
List of simulants
85/572/EEC
Council Directive of 19 December 1985 laying down the list of simulants to be used for
testing migration of constituents of plastic materials and articles intended to come into contact
with foodstuffs.
O.J. L372, of 31.12.1985, p.14
(Plastics: list of simulants for testing migration, consolidated by the rules in Regulation (EU)
No 10/2011 as of 01/01/2013)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
11 of 71
2001/62/EC
Commission Directive of 9 August 2001 amending Directive 90/128/EEC relating to plastics
materials and articles intended to come into contact with foodstuffs.
O.J. L221, of 17 August 2001, p.18
(Plastics: 6th amendment, repealed by Directive 2002/72/EC)
99/91/EC
Commission Directive of 23 November 1999, amending Directive 90/128/EEC relating to
plastics materials and articles intended to come into contact with foodstuffs.
O.J. L310, of 4 December 1999, p.41
(Plastics: 5th amendment, repealed by Directive 2002/72/EC)
96/11/EC
Commission Directive of 5 March 1996, amending Directive 90/128/EEC relating to plastics
materials and articles intended to come into contact with foodstuffs.
O.J. L61, of 12 March 1996, p.26
(Plastics: 4th amendment, repealed by Directive 2002/72/EC)
95/3/EC
Commission Directive of 14 February 1995, amending Directive 90/128/EEC relating to
plastics materials and articles intended to come into contact with foodstuffs.
O.J. L41, of 23 February 1995, p.44
(Plastics: 3rd amendment, repealed by Directive 2002/72/EC)
93/9/EEC
Commission Directive of 15 March 1993 amending for the second time Directive 90/128/EEC
relating to plastics materials and articles intended to come in contact with foodstuffs
O.J. L90, of 14.4.93, p.26
(Plastics: 2nd amendment, repealed by Directive 2002/72/EC)
92/39/EEC
Commission Directive of 14 May 1992, amending Directive 90/128/EEC concerning plastics
materials and articles intended to come into contact with foodstuffs.
O.J. L168, of 23.06.1992, p.21
(Plastics: Ist amendment, repealed by Directive 2002/72/EC)
90/128/EEC
Commission Directive of 23 February 1990 relating to plastics materials and articles intended
to come into contact with foodstuffs.
O.J. L75, of 21.03.1990, p.19
(Plastics: general rules, repealed by Directive 2002/72/EC)
Corrigendum O.J. n° L349 of 13.12.1990, p.26
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
12 of 71
Repealed:
2004/13/EC
Commission Directive of 29 January 2004 amending Directive 2002/16/EC on the use of
certain epoxy derivatives in materials and articles intended to come into contact with
foodstuffs
O.J. L27, of 30.01.2004, p.46
(BADGE, BFDGE, NOGE: 1st amendment to Directive 2002/16/EC; repealed by Regulation
(EC) No 1895/2005)
2002/16/EC
Commission Directive of 20 February 2002 on the use of certain epoxy derivatives in
materials and articles intended to come into contact with foodstuffs.
O.J. L51, of 22.02.2002, p.27
(BADGE/BFDGE/NOGE, repealed by Regulation (EC) 1895/2005)
2001/61/EC
Commission Directive of 8 August 2001 on the use of certain epoxy derivatives in materials
and articles intended to come into contact with foodstuffs.
O.J. L215, of 9 August 2001, p.26
(BADGE/BFDGE/NOGE, repealed by Directive 2002/16/EC)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
13 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
14 of 71
Hygiene of foodstuffs
(EC) No 852/2004
Regulation of the European Parliament and of the Council of 29 April 2004 on the hygiene of
foodstuffs
OJ L 139, of 30.4.2004
Corrigendum to Regulation (EC) No 852/ OJ L 226 of 25.6.2004, p. 3–21
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
Marketing and use of certain dangerous substances and preparations
76/769/EEC
Council Directive of 27 July 1976 on the approximation of the laws, regulations and
administrative provisions of the Member States relating to restrictions on the marketing and
use of certain dangerous substances and preparations
OJ L 262, of 27.9.1976, p. 201–203
Marketing and use of certain dangerous substances and preparations: tin, PCP and
cadmium: 1999/51/EC
Commission Directive of 26 May 1999 adapting to technical progress for the fifth time
Annex I to Council Directive 76/769/EEC on the approximations of the laws, regulations,
and administrative provisions of the Member States relating to restrictions on the marketing
and use of certain dangerous substances and preparations (tin, PCP and cadmium).
16 of 71
See the document below. For further information on national legislation, you can contact National
Authorities (see addresses in the document “EU and National Authorities”)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
17 of 71
Part III:
COMPENDIUM OF NATIONAL
LEGISLATION ON FOOD
CONTACT MATERIALS AND
ARTICLES
January 2012
WARNING!
This document does not claim to be a complete compilation. It is based on information provided
by Member States to the Commission Services.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
18 of 71
AUSTRIA
(last update 16/09/2010)
SUMMARY
All EC Directives implemented as listed below.
Additional national provisions.
Legislation published in the Federal Law Gazette: www ris .bka.gv.at
web site: http://www.ris.bka.gv.at
Legislation is made under powers of the "Lebensmittelsicherheits- und Verbraucherschutzgesetz“ (LMSVG),
BGBl. I Nr. 13/2006, which also implements and incorporates relevant EC-Regulations (e.g. 1935/2004/EC, 882/2004/EC,
1895/2005/EC); the Bundesgesetz gegen den unlauteren Wettbewerb 1984, BGBl. Nr. 448/2984, Chemikaliengesetz, BGBl.
Nr. 53/1997 Teil I, and Abfallwirtschaftsgesetz, BGBl. Nr. 325/1990.
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Lebensmittelsicherheits- und Verbraucherschutzgesetz“ - LMSVG Food Safety and
Consumer Protection Act,
BGBl. I Nr. 13/2006, which also implements and incorporates the relevant EC-Regulations
(e.g. 1935/2004/EC, 882/2004/EC, 1895/2005/EC)
PLASTICS Monomers & additives
Lebensmittelsicherheits- und Verbraucherschutzgesetz – LMSVG
2002/72/EC BGBl. I Nr. 13/2006 i.d.g.F.
Kunststoffverordnung 2003
[Full title - Verordnung der Bundesministerin für Gesundheit und Frauen über
Gebrauchsgegenstände aus Kunststoff, die für die Verwendung bei Lebensmitteln und
Verzehrprodukten bestimmt sind]
BGBl. II Nr. 476/2003
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
19 of 71
Geschirrverordnung
BGBl. 258/1960 ausgegeben am 23/11/1960 (meanwhile partly replaced by Ceramics-Dir., Plastics-Directive)
Keramik-Verordnung
BGBl. Nr. 893/1993: additional regulation of the migration of Ba, Sb, Zn in ceramics, enamel
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
BELGIUM
(last update 26/01/2012)
SUMMARY
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
RÈGLEMENT (CE) No 1935/2004 DU PARLEMENT EUROPÉEN ET DU CONSEIL du 27 octobre 2004 concernant les matériaux
et objets destinés à entrer en contact avec des denrées alimentaires et abrogeant les directives 80/590/CEE et 89/109/CEE
PLASTIC VINYL CHLORIDE MONOMER
78/142/EEC Arrêté royal du 3 juillet 2005 relatif aux matériaux et aux objets en matière plastique destinés
à entrer en contact avec les denrées alimentaires
80/766/EEC Arrêté royal du 11 mars 1983 fixant les méthodes d'analyses pour la détermination du
chlorure de vinyle dans les matériaux et objets destinés à entrer en contact avec les denrées
alimentaires et du chlorure de vinyle cédé par les matéraiux et objets aux denrées
alimentaires.
81/432/EEC Arrêté royal du 11 mars 1983 fixant les méthodes d'analyses pour la détermination du
chlorure de vinyle dans les matériaux et objets destinés à entrer en contact avec les denrées
alimentaires et du chlorure de vinyle cédé par les matéraiux et objets aux denrées
alimentaires.
REGENERATED CELLULOSE FILM
93/10/EEC Arrêté royal du 23 novembre 2004 relatif aux matériaux et aux objets en pellicule de cellulose
93/111/EC régénérée, destinés à entrer en contact avec les denrées alimentaires
2004/14/EC
CERAMIC
84/500/EEC Arrêté royal 1er mai 2006 relatif à la déclaration de conformité et aux critères de performance
2005/31/EC de la méthode d’analyse des objets céramiques destinés à entrer en contact avec les denrées
alimentaires
BULGARIA
(last update 12/01/2012)
SUMMARY
All EC Directives implemented.
No additional national provisions.
Legislation implemented by the Ordinance No 2 of 23 January 2008 relating to plastic materials and articles, intended to come
into contact with foodstuffs, Ordinance № 3 of 4 June 2007 on specific requirements to materials and articles other than plastics
intended to come into contact with foodstuffs and Ordinance No 4 of 10 May 2006 on certain epoxy derivatives, used in the
manufacturing of materials and articles, intended to come into contact with foodstuffs, which give effect in Bulgaria to EU
Directives on food contact materials.
Made under the Law on Foodstufss.
Bulgarian legislation on materials and articles intented to come into contact with foodstuff is published in the Bulgarian State
Gazette, "Държавен вестник (ДВ)", web site address is: http://dv.parliament.bg or www.lex.bg
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC) No 1935/2004 Закон за изменение на Закона за храните (ДВ, бр. 31 от 2006 г. посл. изм. ДВ. бр.41
от 2 Юни 2009г.)
ЗАКОН ЗА ХРАНИТЕ (Обн., ДВ, бр. 90 от 15.10.1999 г.; изм. и доп., бр. 102 от
2003 г.; изм., бр. 70 от 2004 г.; изм. и доп., бр. 87 от 2005 г.; изм., бр. 99 от 2005 г.,
бр. 105 от 2005 г., бр. 30 от 2006 г.; изм. и доп., бр. 31 от 2006 г., бр. 34 от 2006 г.;
изм., бр. 51 от 2006 г.; изм. и доп., бр. 55 от 2006 г., бр. 96 от 2006 г.; изм., бр. 31 от
2007 г.; изм. и доп., бр. 51 от 2007 г.; изм., бр. 36 от 2008 г., бр. 69 от 2008 г.; доп.,
бр. 23 от 2009 г., бр. 41 от 2009 г.; изм., бр. 74 от 2009 г., бр. 82 от 2009 г., бр. 93 от
2009 г.; доп., бр. 23 от 2010 г., бр. 25 от 2010 г.; изм. и доп., бр. 59 от 2010 г.; доп.,
бр. 80 от 2010 г.; изм., бр. 98 от 2010 г.; изм. и доп., бр. 8 от 25.01.2011 г.)
Law on amendment and supplement of the Law on Foodstuffs (State Gazette No 31 of 2006,
last amend No.8 of 2011)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
22 of 71
Ordinance № 3 of 4 June 2007 on specific requirements tomaterials and articles other than
plastics intended to come into contact with foodstuffs (State Gazette No 51 of 26.06.2007 м.
amend. SG No.13 of 8 February 2008, SG.83 of 23 Sept. 2008)
CERAMICS
84/500/EEC Наредба № 3 от 4 юни 2007 г. за специфичните изисквания към материалите и
2005/31/EC предметите, различни от пластмаси, предназначени за контакт с храни (Обн. ДВ. бр.51
от 26 Юни 2007г. изм. ДВ. бр.13 от 8 Февруари 2008г., изм. ДВ. бр.83 от 23 Септември
2008г.),
Ordinance № 3 of 4 June 2007 on specific requirements tomaterials and articles other than
plastics intended to come into contact with foodstuffs (State Gazette No 51 of 26.06.2007 м.
amend. SG No.13 of 8 February 2008, SG.83 of 23 Sept. 2008)
revoked by Ordinance № 3 of 4 June 2007 on specific requirements tomaterials and articles
other than plastics intended to come into contact with foodstuffs (State Gazette No 51 of
26.06.2007)
RUBBER: N-NITROSAMINES
93/11/EEC Наредба № 3 от 4 юни 2007 г. за специфичните изисквания към материалите и
предметите, различни от пластмаси, предназначени за контакт с храни (Обн. ДВ. бр.51
от 26 Юни 2007г. изм. ДВ. бр.13 от 8 Февруари 2008г., изм. ДВ. бр.83 от 23 Септември
2008г.),
Ordinance № 3 of 4 June 2007 on specific requirements tomaterials and articles other than
plastics intended to come into contact with foodstuffs (State Gazette No 51 of 26.06.2007 м.
amend. SG No.13 of 8 February 2008, SG.83 of 23 Sept. 2008)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
23 of 71
CYPRUS
(last update 03/01/2012)
SUMMARY
The Regulations [(EC) No 1935/2004 as amended, and (EC) No 1895/2005, (EC) No 2023/2006, (EC) No 372/2007 (as
amended), (EC) No 282/2008, (EC) No 450/2009 and (EC) No 10/2011 (as amended)] are implemented as such. and aAll EC
Directives [82/711/EEC (as amended), 85/572/EEC, 78/142/EEC, 2007/42/EC, 93/11/EEC and 1984/500/EEC (as amended) are
implemented and incorporated in the following Cyprus national Regulations:
o The Materials and Articles for Contact with Foodstuffs Regulations of 2004: published in Cyprus Official Gazette,
E.E.Παρ. ΙΙΙ (I), Αρ.3850, 30.4.2004,Κ.Δ.Π.450/2004;
o The Materials and Articles for Contact with Foodstuffs (Amendment) Regulations of 2005 amending the basic
Regulations of 2004: published in Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 3988, 6.5.2005, Κ.Δ.Π. 225/2005.
o The Materials and Articles for Contact with Foodstuffs (Amendment) (No. 2) Regulations of 2005, E.E.Παρ. ΙΙΙ (I), Αρ.
4060, 23.12.2005, Κ.Δ.Π. 575/2005
o The Materials and Articles for Contact with Foodstuffs (Amendment) Regulations of 2006, E.E.Παρ. ΙΙΙ (I), Αρ. 4120
14.07.2006, Κ.Δ.Π. 291/2006
o The Materials and Articles for Contact with Foodstuffs (Amendment) (No. 2) Regulations of 2006, E.E.Παρ. ΙΙΙ (I), Αρ.
4120, 14.07.2006, Κ.Δ.Π.292/2006
o The Materials and Articles for Contact with Foodstuffs (Amendment) (No. 3) Regulations of 2006, E.E.Παρ. ΙΙΙ (I), Αρ.
4161, 29.12.2006, Κ.Δ.Π.483/2006
o The Materials and Articles for Contact with Foodstuffs (Amendment) Regulations of 2008, E.E.Παρ. ΙΙΙ (I), Αρ. 4289,
4.7.2008, Κ.Δ.Π.251/2008
o The Materials and Articles for Contact with Foodstuffs (Amendment) Regulations of 2009, E.E.Παρ. ΙΙΙ (I), Αρ. 4363,
5.6.2009, Κ.Δ.Π.230/2009
These regulations have been enacted and edited under the Food (Control and Safe) Law, published in Cyprus Official Gazette,
(Κ.Δ.Π. = Regulatory Administrative Act, Αρ.= Νο , E.E.Παρ. =Official Gazette Appendix)
The State General Laboratory is the official laboratory for the food contact materials and the Health Services are the competent
authority for the implementation of the above Regulations.
Regulations are made under the powers of the Council of Ministers.
Regulations are published in the Cyprus Official Gazette (Επίσημη Εφημερίδα της Κυπριακής Δημοκρατίας) after its approval
by the Parliament.
http://www.mof.gov.cy/gpo http://www.cygazette.com
Sales Agent:
Government printing office of the Republic of Cyprus
1445 Nicosia
Tel. 00357-22 405801-802
Fax. 00357-22 303175
97/48/EC (2nd amend.to 82/711/EEC) Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 3850, 30.4.2004, Κ.Δ.Π. 450/2004
85/572/EEC (list of simulants for testing Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 3850, 30.4.2004, Κ.Δ.Π. 450/2004
migration)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
24 of 71
Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 3850, 30.4.2004, Κ.Δ.Π. 450/2004
Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 4060, 23.12.2005, Κ.Δ.Π. 575/2005
CERAMICS
84/500/EEC Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 3850, 30.4.2004, Κ.Δ.Π. 450/2004
2005/31/EC (amendment to 84/500/EC) Cyprus Official Gazette, E.E.Παρ. ΙΙΙ (I), Αρ. 4120, 14.07.2006, Κ.Δ.Π. 292/2006
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
25 of 71
CZECH REPUBLIC
(last update 07/05/2007)
SUMMARY
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC)1935/2004 Zákon 258/2000 Sb., o ochraně veřejného zdraví a o změně
některých souvisejících zákonů v platném znění
(zákon ze dne 14.července 2000, vydaný ve Sbírce zákonů České
republiky, částce 74, dne 11.8.2000)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
26 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
DENMARK
(last update 21/12/2011)
SUMMARY
a. Cirkulære nr. 9193 af 1. juni 2011 om kontrol med materialer og genstande bestemt til kontakt med fødevarer.
Made under powers of the General Food Act.
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS, INCLUDING SPECIFIC MATERIALS
All EC directives on food contact Fødevarestyrelsens Bekendtgørelse nr. 579 af 1. juni 2011 om materialer og genstande
materials bestemt til kontakt med fødevarer. Ministeriet for Fødevarer, Landbrug og Fisk
SUMMARY
IMPLEMENTATION OF EC DIRECTIVES
(Government Regulation No 156 of 17. 05. 1999 ”The requirements for materials and
articles intended to come into contact with foodstuffs, specific requirements for the groups
of materials and articles and methods of analysis for official control”)
FINLAND
(last update 20/01/2012)
SUMMARY
Legislation on food contact materials and articles is available on the internet pages of the Ministry of Agriculture and Forestry:
http://www.mmm.fi/fi/index/etusivu/elintarvikkeet/elintarvikekontaktimateriaalit.html
E-mail: asiakaspalvelu.publishing@edita.fi
Website: www.edita.fi/netmarket
IMPLEMENTATION OF EC DIRECTIVES
PLASTICS Testing
82/711/EEC (basic rules) Kauppa- ja teollisuusministeriön päätös elintarvikkeen kanssa kosketukseen joutuvien
muovisten tarvikkeiden sisältämien ainesosien siirtymisen testaamiseen tarvittavista
93/8/EEC (1st amend. 82/711/EEC)
perussäännöistä (487/1998) 23/06/1998. Codified version.
97/48/EC (2nd. amend. 82/711/EEC)
85/572/EEC (simulants) Kauppa- ja teollisuusministeriön päätös elintarvikkeen kanssa kosketukseen joutuvien
muovisten tarvikkeiden sisältämien aineosien migraation testaamiseen käytettävistä
simulanteista (262/92) 20/03/1992
REGENERATED CELLULOSE FILM
2004/14/EC Kauppa- ja teollisuusministeriön asetus (697 /2005; 28.8.2005) elintarvikkeen kanssa
93/111/EC kosketukseen joutuvien tarvikkeiden valmistuksessa käytettävästä regeneroidusata
93/10/EC selluloosasta valmistetusta kalvosta. Codified version.
CERAMICS
84/500/EEC, amend. 2005/31/EC Kauppa- ja teollisuusministeriön asetus elintarvikkeen kanssa kosketukseen joutuvista
keraamisista tarvikkeista (165/2006) 21/02/2006. Codified version.
RUBBER, N-nitrosamines:
93/11/EEC Kauppa ja teollisuusministeriön päätös 903/1994 N-nitrosamiinien ja N-nitrosoituvien
aineiden vapautumisesta elastomeeristä tai kumista valmistetuista tuttipullon tuteista ja
huvituteista
Kauppa- ja teollisuusministeriön päätös elintarvikkeen kanssa Heavy metals migrating from food contact materials and articles
kosketukseen joutuvista tarvikkeista liukenevista
raskasmetalleista (268/92) 20/03/1992
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
FRANCE
(last update 01/09/2009)
SUMMARY
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
R.(CE) n° 1935/2004 Décret Numéro 2007-766 du 10 ami 2007 modifié portant application du code de la
consommation en ce qui concerne les matériaux et objets destinés à entrer au contact des
denrées (décret sanctions du règlement + mesures nationales) .
80/590/EEC (symbol) Arrêté ministériel du 28/01/1983 relatif à la détermination du symbole pouvant accompagner
les matériaux et objets qui ne doivent pas entrer en contact avec des denrées, produits et
boissons alimentaires
Numéro complémentaire du J.O. du 25/02/1983, p. 2143
PLASTICS Monomers & additives
90/128/EEC (monomer/additive lists) Arrêté ministériel du 14/09/1992 relatif aux matériaux et objets en matière plastique mis ou
destinées à être mis au contact des denrées, produits et boissons alimentaires
J.O. du 13/10/1992, p. 14240
Arrêté ministériel du 14/09/1992 modifiant et complétant l'arrêté du 19/12/1988 relatif aux
règles de base nécessaires à la vérification de la migration des constituants de matériaux et
objets en matière plastique au contact des denrées, produits et boissons alimentaires et fixant
la liste des simulateurs à utiliser pour vérifier cette migration
J.O. du 25/09/1992, p. 13327
92/39/EEC (1st amend. 90/128/EEC) Arrêté ministériel du 14/09/1992 relatif aux matériaux et objets en matière plastique mis ou
destinées à être mis au contact des denrées, produits et boissons alimentaires
J.O. du 13/10/1992, p. 14240
93/9/EEC (2nd amend. 90/128/EEC) Arrêté du 20/01/1994 modifiant l'arrêté ministériel du 14/09/1992 relatif aux matériaux et
objets en matière plastique mis ou destinées à être mis au contact des denrées, produits et
boissons alimentaires
J.O. du 16/02/1994, p. 2650
95/3/EC (3rd amend. 90/128/EEC) Arrêté du 30/09/1997 modifiant l'arrêté ministériel du 14/09/1992 relatif aux matériaux et
96/11/EC (4th amend. 90/128/EEC) objets en matière plastique mis ou destinées à être mis au contact des denrées, produits et
boissons alimentaires
J.O. du 19/10/1997, p. 15227
99/91/EC (5th amend.90/128/EEC) Arrêté du 3 janvier 2001 modifiant l’arrêté du 14 septembre 1992 relatif aux matériaux et
objets en matière plastique mis ou destinées à être mis au contact des denrées, produits et
boissons alimentaires
J.O. du 06/02/2001, p. 2002
2002/72/EC (Consolidation Arrêté du 2 janvier 2003 relatif aux matériaux et objets en matière plastique mis ou destinées
90/128/EEC and its 7 amendments) à être mis au contact des denrées, produits et boissons alimentaires
J.O. du 29/01/2003, p.1771
2004/1/EC (1st amend 2002/72/EC) Arrêté du 29 mars 2005 modifiant l’A. du 02/01/2003 relatif aux matériaux et objets en
matière plastique mis ou destinées à être mis au contact des denrées, produits et boissons
alimentaires J.O.du 13/04/2005.
2004/19/EC (2nd amend2002/72/EC) Arrêté du 9 août 2005 modifiant l’A. du 02/01/2003relatif aux matériaux et objets en matière
plastique mis ou destinées à être mis au contact des denrées, produits et boissons
alimentaires- JO du 16/10/2005.
2005/79/EC (3rd amend 2002/72/EC) Arrêté du 19 octobre 2006 modifiant l’A. du 02/01/2003relatif aux matériaux et objets en
matière plastique mis ou destinées à être mis au contact des denrées, produits et boissons
alimentaires- JO du 10/11/2006.
2007/19/EC (4th amend 2002/72/EC) Arrêté du 25 avril 2008 modifiant l’A. du 02/01/2003relatif aux matériaux et objets en
matière plastique mis ou destinées – JO du 29/06/2008.
2008/39/EC(5th amend 2002/72/EC) Arrêté du 19 novembre 2008 modifiant l’A. du 02/01/2003relatif aux matériaux et objets en
matière plastique mis ou destinées – JO du 7/12/2008.
31 of 71
PLASTICS Testing
82/711/EEC (basic rules) Arrêté du 19/12/1988 relatif aux règles de base nécessaires à la vérification de la migration
85/572/EEC (simulants) des constituants de matériaux et objets en matière plastique au contact des denrées, produits
et boissons alimentaires et fixant la liste des simulateurs à utiliser pour vérifier cette
migration
J.O. du 27/12/1988, p. 16264
93/8/EEC (1st amend. 82/711/EEC) Arrêté du 16/05/1994 modifiant l'arrêté du 14/09/1992 relatif aux matériaux et objets en
matière plastique mis ou destinées à être mis au contact des denrées, produits et boissons
alimentaires
J.O. du 26/05/1994, p. 7618
97/48/EC (2nd. amend. 82/711/EEC) Arrêté du 20/04/1998 modifiant l'arrêté du 14/09/1992 relatif aux matériaux et objets en
matière plastique mis ou destinées à être mis au contact des denrées, produits et boissons
alimentaires
J.O. du 07/05/1998, p.
PLASTICS Vinyl chloride monomer
78/142/EEC Arrêté du 30/01/1984 relatif aux matériaux et objets en matière et objets contenant du
chlorure de vinyle monomère et destinées à être mis au contact des denrées, produits et
boissons alimentaires
Numéro complémentaire du J.O. du 12/02/1984, p.
80/766/EEC Arrêté du 30/01/1984 relatif aux méthodes officielles d’analyse concernant la détermination
81/432/EEC de la teneur en chlorure de vinyle monomère des matériaux et objets destinées à entrer en
contact avec les denrées, produits et boissons alimentaires et la détermination de la teneur du
chlorure de vinyle cédé par les matériaux et objets aux denrées, produits et boissons
alimentaires mis à leur contact
Numéro complémentaire du J.O. du 12/02/1984, p.
CERAMICS
84/500/EEC Arrêté ministériel du 07/11/1985 relatif à la limitation des quantités de plomb et de cadmium
extractibles des objets en céramique mis ou destinés à être mis au contact des denrées,
produits et boissons alimentaires
J.O. du 01/12/1985, p.13942
Arrêté du 09/11/1994 relatif aux matériaux et objets en caoutchouc au contact des rubbers
denrées, produits et boissons alimentaires mis ou destinées à être mis au contact des
denrées, produits et boissons alimentaires
J.O. du 02/12/94, p.
PAPER AND BOARD
Arrêté du 28/06/1912 (articles 7) modifié relatif à la coloration, à la conservation et à
l’emballage des denrées alimentaires et boissons
J.O. du 29/06/1912, p.
Circulaires, instructions, lettres-circulaires réunies dans la brochure n° 1227 dans Additives for paper and board
lesquelles sont cités les additifs dont l’utilisation a été admise
Arrêté du 15/11/1945 fixant la liste des matériaux susceptibles d’être utilisés sans
inconvénient pour la santé publique dans la fabrication des instruments de mesure
J.O. du18/11/1945, p.
WOOD
Arrêté du 15/11/1945 fixant la liste des matériaux susceptibles d’être utilisés sans
inconvénient pour la santé publique dans la fabrication des instruments de mesure
J.O. du18/11/1945, p.
Les substances de traitement du bois admises après avis favorable du Conseil Substances for treating wood
supérieur d’hygiène publique de France sont cités dans la brochure n° 1227
IRRADIATION TREATMENT
Arrêté du 12/08/1986 relatif au traitement par rayonnements ionisants
des matériaux et objets mis au contact des denrées, produits et boissons
alimentaires
J.O. du 20/08/86, p.
Arrêté du 23 juin 2006 modifiant l’A. du 12/08/1986.JO du 05/07/2006.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
33 of 71
GERMANY
(last update 20/12/2011)
SUMMARY
All EC Directives implemented.
Additional national recommendations.
Legislation published in the Bundesgesetzblatt Teil I (BGBl. I).
Legislation is made under powers of the Lebensmittel- und Futtermittelgesetzbuch [Food and Feed law].
Sales Point: Bundesanzeiger Verlagsges.mbH. Köln
Amsterdamer Str. 192, 50 735 Köln
Tel.: +49/ –221/ 97668-0
Fax: +49/ –221/ 97668-278
E-mail: vertrieb(a)bundesanzeiger.de
WebSite: www.bundesanzeiger.de
IMPLEMENTATION OF EC DIRECTIVES
92/39/EEC (1st amend. 90/128/EEC) Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 11. April 1994
(BGBl. I S. 775) ∗)
93/9/EEC (2nd amend. 90/128/EEC) Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 11. April 1994
(BGBl. I S. 775) ∗)
95/3/EC (3rd amend. 90/128/EEC) Fünfte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 17. April
1997 (BGBl. I S. 796) ∗)
96/11/EC (4th amend. 90/128/EEC) Fünfte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 17. April
1997 (BGBl. I S. 796) ∗)
99/91/EC (5th amend. 90/128/EEC) Achte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 21. Dezember
2000 (BGBl. I S. 1886)
2001/62/EC (6th amend 90/128/EEC) Neunte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 7. April
2003 (BGBl. I S. 486)
2002/17/EC (7th amend 90/128/EEC) Neunte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 7. April
2003 (BGBl. I S. 486)
2004/1/EC (1st amend 2002/72/EC) Elfte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 13. Juli 2005
(BGBl. I S. 2150)
2004/19/EC (2nd amend 2002/72/EC) Elfte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 13. Juli 2005
(BGBl. I S. 2150)
2005/79/EC (3rd amend 2002/72/EC) Zwölfte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 30.
November 2006 (BGBl. I S. 2730)
2007/19/EC (4th amend 2002/72/EC) Fünfzehnte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 30. April
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
34 of 71
93/8/EEC (1st amend. 82/711/EEC) Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 11. April 1994
(BGBl. I S. 775) ∗)
97/48/EC (2nd. amend. 82/711/EEC) Verordnung zur Änderung der Technische Hilfsstoff-Verordnung und zur Änderung der
Bedarfsgegenständeverordnung vom 26. November 1998 (BGBl. I S. 3492)
2004/14/EC (2nd amend 93/10/EEC) Elfte Verordnung zur Änderung der Bedarfsgegenständeverordnung vom 13. Juli 2005
(BGBl. I S. 2150)
2005/31/EC (1st amend. Zweite Verordnung zur Änderung der Bedarfsgegenständeverordnung und der
84/500/EEC) KosmetikVerordnung vom 30. Mai 2006 (BGBl. I S. 1279)
∗)
Revised version including all amendments until December 1997:
Bedarfsgegenständeverordnung in der Fassung der Bekanntmachung vom 23. Dezember 1997
(BGBl. I 1998 S. 5), zuletzt geändert durch die Zwanzigste Verordnung zur Änderung der Bedarfsgegenständeverordnung vom
7. Febraur 2011 (BGBl. I S. 226).
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
35 of 71
GREECE
(last update 22/12/2011)
SUMMARY
IMPLEMENTATION OF EC DIRECTIVES
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
37 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
38 of 71
HUNGARY
(last update 21/12/2011)
SUMMARY
EC Directives implemented as listed bellow
Additional national provisions
Laws and Regulations are published in Magyar Közlöny
Legislations are published as the Codex Alimentarius Hungaricus in Vidékfejlesztési Értesítő
Sales Agent: Magyar Közlöny Lap- és Könyvkiadó
H-1085 Budapest
Somogyi Béla u. 6.
Tel.: +36 1 266 9290
www.mhk.hu
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC) Number 1935/2004 Directly applicated.
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 29. – repealed based on (EU) No 10/2011 Reulation
PLASTICS TESTING
Repealed:
82/711/EEC (basic rules) Codex Alimentarius Hungaricus 1-2-82/711 (1993)
85/572/EEC (simulants) Az Az élelmiszerekkel érintkezésbe kerülõ mûanyagok és mûanyag tárgyak
komponenseinek kioldódási vizsgálatai
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 26.
Repealed:
93/8/EEC (1st amend. 82/711/EEC) Codex Alimentarius Hungaricus 1-2-82/711 (1993)
Az élelmiszerekkel érintkezésbe kerülõ mûanyagok és mûanyag tárgyak komponenseinek
kioldódási vizsgálatai
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 26.
Repealed:
97/48/EC (2nd. amend. 82/711/EEC) Codex Alimentarius Hungaricus 1-2-82/711 (2000)
Az élelmiszerekkel érintkezésbe kerülõ mûanyagok és mûanyag tárgyak komponenseinek
kioldódási vizsgálatai
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 26.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
39 of 71
Repealed:
Codex Alimentarius Hungaricus 1-2-80/766 (1993)
80/766/EEC Élelmiszerrel érintkezésbe kerülõ anyagok és tárgyak vinil-klorid monomer tartalmának
meghatározása
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 27. – repealed based on (EU) No 10/2011 Reulation
Repealed:
81/432/EEC Codex Alimentarius Hungaricus 1-2-81/432 (1993)
A közszükségleti cikkekbõl az élelmiszerekbe kioldódó vinil-klorid mennyiségének
meghatározása
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 28. – repealed based on (EU) No 10/2011 Reulation
Repealed:
2007/42/EC (Codified version) Codex Alimentarius Hungaricus 1-2-2007/42 (2007) Consolidated
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 25.
CERAMICS
Repealed:
84/500/EEC Codex Alimentarius Hungaricus 1-2-84/500 (1993)
Az élelmiszerekkel érintkezésbe kerülõ kerámiatárgyak
2005/31(amend. 84/500/EEC) Codex Alimentarius Hungaricus 1-2-2002/16 (2005) Consolidated
Transferred into 152/2009. (XI. 12.) FVM regulation (Codex Alimentarius Hungaricus) in
Annex 24.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
40 of 71
IRELAND
(last update 5/08/2010)
SUMMARY
EC legislation implemented as listed below.
No additional national provisions.
Legislation implemented by the European Communities (Plastics and other materials)(Contact with food) Regulations, 2007,
which give effect in Ireland to EU legislation on food contact materials.
Made under the European Communities Act 1972.
Legislation available on www.irishstatutebook.ie and on the website of the Food Safety Authority of Ireland (www.fsai.ie) at
the following link: http://www.fsai.ie/legislation/food_legislation/materials_articles/introduction.html
Sales Point: Government Publications
Sun Alliance House
Molesworth St. - Dublin 2
Tel: +353 1 6613111
Fax: +353 1 4752760
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
All EU directives, regulations and European Communities (Plastics and other materials)(Contact with food) Regulations,
decisions on food contact materials 2007 (S.I. No. 587 of 2007), as amended by:
• the European Communities (Plastics and other materials)(Contact with food)
(Amendment) Regulations 2009 (S.I. No. 88 of 2009);
• the European Communities (Plastics and other materials)(Contact with food)
(Amendment) (No. 2) Regulations 2009 (S.I. No. 463 of 2009);
• the European Communities (Plastics and other materials)(Contact with food)
(Amendment) (No. 2) Regulations 2010 (S.I. No. 301 of 2010)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
41 of 71
ITALY
(last update 05/01/2012)
SUMMARY
EC Directives implemented as listed below.
Additional national provisions.
Legislation published in the Official Gazette (G.U.).
Legislation is made under the powers of Law No. 283 of 30.4.1962 and the Ministerial Decree of 21 March 1973. General and/
or specific national previsions also implement and incorporate relevant EC-Regulations (e.g. 1935/2004/EC, 2023/2006/EC,
882/2004/EC);
Sales Agent: Istituto Poligrafico e Zecca dello Stato
P.zza G. Verdi, 10
Tel.+39.0685081
Fax:+39.0685082517
Website: http://www.ipzs.it
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
89/109/EEC (framework) Law No. 283 of 30.4.1962: Disciplina igienica della produzione e della vendita delle
sostanze alimentari e delle bevande (Modificata dalla legge 26 febbraio 1963, n. 441).
G.U. n. 139 del 4-6-1962
Legislative Decree No. 108 of 25.1.92: Attuazione della Direttiva 89/109/CEE
concernente i materiali e gli oggetti destinati a venire a contatto con i prodotti alimentari.
Pubblicato nel supplemento ordinario n. 31 alla
G.U. Serie Generale n. 39 del 17-2-1992 pag. 1201
DPR No. 777 23.8.82: Attuazione della direttiva (CEE) n. 76/893 relativa ai materiali e
agli oggetti destinati a venire a contatto con i prodotti alimentari.
G.U. n. 298 del 28/10/1982
93/9/EEC (2nd amend. 90/128/EEC) Decree of the Ministry of Health No. 735 of 28.10.94
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Attuazione delle direttive 93/8/CEE
e 93/9/CEE.
G.U. n.1 del 2-1-1995 pag.3
95/3/EC (3rd amend. 90/128/EEC) Decree of the Ministry of Health No. 572 of 24.9.96
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Recepimento della direttiva 95/3/CE
S.O n.195 alla G.U. n. 264 del 11-11-1996
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
42 of 71
96/11/EEC (4th amend. 90/128/EEC) Decree of the Ministry of Health No. 91 of 6.2.97
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Recepimento della direttiva
96/11/CE.
G.U. n. 77 del 3-4-1997 pag. 28
99/91/EEC (5th amend. 90/128/EEC) Decree of the Ministry of Health No. 210 of 15.6.2000
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Recepimento della direttiva n.
99/91/CE.
G.U. n. 175 del 28-7-2000 pag. 8
2001/62/EC (6th amend. 90/128/EEC) Decree of the Ministry of Health No. 123 of 28.3.2003
2002/17/EC (7th amend. 90/128/EEC) Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Recepimento delle direttive n.
2001/62/CE, 2002/16/CE e 2002/17/CE.
S. O. n.89/L alla G.U. n. 125 del 31-5-2003 (N.89/L)
2004/1/EC (1th amend. 2002/72/EC) Decree of the Ministry of Health No 227 of 4.5.2006
2004/19/EC (2th amend. 2002/72/EC) Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Recepimento delle direttive n.
2004/1/CE, 2004/13/CE e 2004/19/CE.
G.U. n. 159 del 11-7-2006 pag. 4
2005/79/EC (3 rd amend. 2002/72/EC) Decree of the Ministry of Health No 82 of 18.4.07
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari o con sostanze d’uso personale. Recepimento della direttiva
2005/79/CE
S.O. n.149/L alla G.U. n. 151 del 2-7-2007
2007/19/CE (4th amend 2002/72/EC) Decree of the Ministry of Health No 174 of 24.9.08
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari o con sostanze d’uso personale. Recepimento della direttiva
2007/19/CE.
S.O. n.246/L alla G.U. n. 261 del 7-11-2008
PLASTICS Testing
82/711/EEC (basic rules) Decree of the Ministry of Health No. 220 of 26.4.93
85/572/EEC (simulants) Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale. Recepimento delle direttive
82/711/CEE, 85/572/CEE, 90/128/CEE e 92/39/CEE.
S.O. n. 64 alla G.U. n. 162 del 13-7-1993
Corrigendum G.U. n. 257 del 2-11-1993
le sostanze alimentari e con sostanze d’uso personale. Attuazione delle direttive 93/8/CEE
e 93/9/CEE.
G.U. n. 1 del 2-1-1995 pag. 3
97/48 EEC Decree of the Ministry of Health n.338 of 30.9.98
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente
la disciplina igienica degli imballaggi, recipienti, utensili destinati a venire in contatto con
le sostanze alimentari e con sostanze d’uso personale, a seguito del recepimento della
direttiva n. 97/48/CE.
G.U. n. 228 del 30-9-1998 pag. 13
amended by:
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
44 of 71
DMH 25.6.81
Aggiornamento del decreto ministeriale 21 marzo 1973, concernente la disciplina igienica degli imballaggi, recipienti, utensili
destinati a venire in contatto con le sostanze alimentari o con sostanze d’uso personale.
G.U. n. 198 del 21-7-1981 pag. 4675
DMH No. 90 of 18.1.91: (integration to positive lists, amemdments to paper and boards)
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973 concernente la disciplina igienica degli imballaggi,
recipienti, utensili destinati a venire in contatto con le sostanze alimentari e con sostanze d’uso personale.
G.U. n. 67 del 20-3-1991 pag.7
DMH No. 220 of 26.4.93: (integration to positive lists, modification to paper and boards too)
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente la disciplina igienica degli imballaggi,
recipienti, utensili destinati a venire in contatto con le sostanze alimentari e con sostanze d’uso personale. Recepimento delle
direttive 82/711/CEE, 85/572/CEE, 90/128/CEE,e 92/39/CEE.
G.U. n. 162 del 13-7-1993 pag. 5.
DMH n.338 del 22.07.1998 (integration to positive lists and purity requirements, migration test conditions)
Regolamento recante aggiornamento del decreto ministeriale 21 marzo 1973, concernente la disciplina igienica degli imballaggi,
dei recipienti e degli utensili destinati a venire in contatto con le sostanze alimentari e con sostanze d’uso personale, a seguito del
recepimento della direttiva n.97/48/CE
G:U n.228 del 30-09-1998 pag. 13
DMH No 76 of 18.4.2007
Regolamento recante la disciplina igienica dei materiali e degli oggetti di alluminio e di leghe di alluminio destinati a venire a
contatto con gli alimenti
G. U. n.141 del 20-6-2007 pag. 5
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
46 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
47 of 71
LATVIA
(last update 22/12/2011)
For information on the transposition of the European Directives on food contact materials and articles please
contact directly the national focal contact point of Latvia:
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS, INCLUDING PAPER AND BOARD
All EC Directives on food contact materials Latvian Regulation Nr.673 of 01.08.2006. “Obligatory
Requirements of Harmless for Materials and Articles
which come into Contact with Foodstuffs” (codified
version).
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
48 of 71
LITHUANIA
(last update 03/01/2012)
SUMMARY
For information on the transposition of the European Directives on food contact materials and articles please contact directly the
Permenant Representation of Lithuania to the European Commission:
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC) No 1935/2004 Lietuvos Respublikos oficialusis leidinys, L, 2004, Nr. 338-4
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
LUXEMBOURG
(last update 03/09/2009)
SUMMARY
EC Directives implemented as listed below.
No additional national provisions.
Legislation on Food Contacts Materials and Articles which comes into contact with foods as enacted by the government of
Luxembourg is published by the Service Central de Legislation, located at 43, bd F-D Roosevelt L-2450 Luxembourg. The
legislation can been download from www.legilux.public.lu
Legislation on food contacts materials and articles were made under the authority of the Ministry of Health.
Sales Agent: Service Central des Imprimés et Fournitures de bureau de l’Etat
22, rue des Bruyères
L-1274 Howald
Tél: +352 49 88 11-1 ; Fax: +352 400 881
E-mail: info@scie.public.lu
IMPLEMENTATION OF EC DIRECTIVES
2002/72/CE Règlement g-d du 25 novembre 2005 (Mémorial “A” n°194 du 07.12.2005, page 3097)
2004/1/CE Règlement g-d du 25 novembre 2005 (Mémorial “A” n°194 du 07.12.2005, page 3097)
2004/19/CE Règlement g-d du 25 novembre 2005 (Mémorial “A” n°194 du 07.12.2005, page 3097)
2005/79/CE Règlement ministériel du 15 juin 2006 (Mémorial “A” n°121 du 13.07.2006, page 2106)
Règlement g-d du 23 octobre 2008 (Mémorial A n°163 du 5 novembre 2008, page 2275)
2007/19/CE
PLASTICS Testing
82/711/CE (basic rules) Règlement grand-ducal du 11 juin 1991 (Mémorial “A” n°44 du 13.07.1991, page 926)
85/572/CE (simulants) Règlement grand-ducal du 11 juin 1991 (Mémorial “A” n°44 du 13.07.1991, page 926)
93/8/CE (1st amend. 82/711/CE) Règlement grand-ducal du 18 mars 1995 (Mémorial “A” n°55 du 10.07.1995, page 1390)
97/48/CE (2nd amend. 82/711/CE) Règlement grand-ducal du 5 février 1999 (Mémorial “A” n°10 du 16.02.1999, page 158)
PLASTICS Vinyl chloride monomer
78/142/CE Règlement g-d du 24 octobre 1978 (Mémorial “A” n°70 du 31.10.1978, page 1422)
80/766/CE Règlement ministériel du 25 août 1982 (Mémorial “A” n°78 du 11.10.1982, page 1715)
81/432/CE Règlement ministériel du 25 août 1982 (Mémorial “A” n°78 du 11.10.1982, page 1715)
REGENERATED CELLULOSE FILM
2007/42/CE/CE
CERAMICS
84/500/CE Règlement grand-ducal du 22 février 1985 (Mémorial “A” n° 10 du 1.03.1985, page 178)
2005/31/CE Règlement g-d du 15 septembre 2006 (Mémorial “A” n° 176 du 4.10.2006, page 3165)
BADGE/BFDGE/NOGE
1895/2005/CE
50 of 71
MALTA
(last update 27/02/2006)
For information on the transposition of the European Directives on food contact materials and articles please contact
directly the national focal contact point of Malta.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
THE NETHERLANDS
(last update 16/09/2010)
SUMMARY
EC Directives implemented as listed below.
Additional national provisions for various food contact materials and articles.
EC Directives implemented by the Dutch Packaging and Food Utensils Regulations under the powers of the Ministry of Health,
Welfare and Sport relate to the following materials: plastics, paper and board, rubber products, metals, glass and ceramics,
ceramics materials and enamels, textile products, regenerated cellulose, wood and cork, coatings and BADGE/BFDGE/NOGE.
Legislation is published in the Staatscourant which is published daily in the Netherlands.
Sales Agent: Servicecentrum Uitgevers
PO Box: 20014
2500 EA Den Haag
Tel.: +31 70 37 89 880
Fax.: +31 70 37 89 783
e-mail: sdu(a)sdu.nl
Website : www.sdu.nl
IMPLEMENTATION OF EC DIRECTIVES
COATINGS
Staatscourant nº 45 of 04/03/1983 135 of 17/07/1984
50 of 10/03/1988
165 of 28/04/1995
214 of 05/11/1996
206 of 24/10/2000
67 of 04/04/2003
166 of 29/08/2007
CERAMICS
Staatscourant nº 18 of 25/01/1980 45 of 04/03/1983
135 of 13/07/1984
50 of 11/03/1988
74 of 17/04/1993
214 of 05/11/1996
206 of 24/10/2000
GLASS
Staatscourant nº 18 of 25/01/1980 45 of 04/03/1983
135 of 13/07/1984
50 of 11/03/1988
74 of 17/04/1993
214 of 05/11/1996
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
53 of 71
206 of 24/10/2000
67 of 04/04/2003
TEXTILES
Staatscourant nº 18 of 25/01/1980 47 of 09/03/1982
50 of 11/03/1988
74 of 17/04/1993
214 of 05/11/1996
206 of 24/10/2000
67 of 04/04/2003
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
54 of 71
NORWAY
(last update 21/12/2011)
Additional national provisions on ceramic articles, glass, metal wares and non-ceramic materials without a coating of enamel.
Regulation on Food Contact Materials in Norway “Forskrift om materialer og gjenstander i kontakt med næringsmidler” (21
December 1993, No 1381) published in Norsk Lovtidend: http://www.lovdata.no/for/sf/ho/xo-19931221-1381.html
Legislation is made under powers of “Lov om matproduksjon og mattrygghet mv” (The Norwegian Food Law) (19 December
2003 No 124) published in Norsk Lovtidend: http://www.lovdata.no/all/hl-20031219-124.html
The power of enforcement under the Norwegian Food Law is delegated from the Ministry of Health and Social Services to the
Norwegian Food Safety Authority.
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC) No. 1935/2004 Regulations 21 December 1993 No 1381 on materials and articles intended to come into
Regulation (EC) No. 2023/2006 contact with foodstuffs Chapter I General regulations.
Regulation (EC) No. 450/2009
Regulation (EC) No. 10/2011
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
55 of 71
POLAND
(last update 20/01/2012)
SUMMARY
All EC directives implemented.
Additional national provisions.
Legislation published in the Dziennik Ustaw Rzeczypospolitej Polskiej [Official Journal] (Dz.U.)
• Legislation is made under the powers of the Act of 25th August 2006 on safety of food and nutrition (OJ 2006 , No 171
item 1225).
• Sales Point:
Centrum Usług Wspólnych
ul. Powsińska 69/71
02-903 Warszawa
Tel.: +48/22/ 694 62 96
Fax: +48/22/ 694 62 06
E-mail: dziust(a)cuw.gov.pl
WebSite: www.cokprm.gov.pl
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC) 1935/2004 Ustawa z dnia 25 sierpnia 2006 r. o bezpieczeństwie żywności i żywienia
(framework) (consolidation Dz. U. z 2010r, Nr 136, poz. 914)
2011/8/EU (restriction of use of Rozporządzenie Ministra Zdrowia z dnia 12 kwietnia 2011r zmieniające
Bisphenol A in plastic infant feeding rozporządzenie w sprawie wykazu substancji, których stosowanie jest dozwolone w
bottles) procesie wytwarzania lub przetwarzania materiałów I wyrobów z tworzyw sztucznych,
a także sposobu sprawdzania zgodności tych materiałów i wyrobów z ustalonymi
limitami (Dz. U. z 2011r, Nr 85, poz. 467)
PLASTICS Testing
82/711/EEC (basic rules) Rozporządzenie Ministra Zdrowia z dnia 22 czerwca 2007r w sprawie wykazu
93/8/EEC (1st amend. 82/711/EEC) substancji, których stosowanie jest dozwolone w procesie wytwarzania lub
97/48/EC (2nd amend. 82/711/EEC) przetwarzania materiałów I wyrobów z tworzyw sztucznych, a także sposobu
sprawdzania zgodności tych materiałów i wyrobów z ustalonymi limitami (Dz. U. z
85/572/EEC (simulants) 2007r, Nr 129, poz. 904)
CERAMICS
84/500/EEC Rozporządzenie Ministra Zdrowia z dnia 15 stycznia 2008r w sprawie wykazu
2005/31/EC (1st amend. 84/500/EEC) substancji, których stosowanie jest dozwolone w procesie wytwarzania lub
przetwarzania materiałów i wyrobów z innych tworzyw niż tworzywa sztuczne
przeznaczonych do kontaktu z żywnością
(Dz. U. z 2008r, nr 17, poz. 113)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
PORTUGAL
(last update 10/07/2009)
SUMMARY
All EC directives implemented.
Additional national recommendations for enamelled ware, glass ware and other ware.
Legislation published in the Diário da República [Official Journal], and associated standards.
Sales Agent: IMPRENSA NACIONAL – CASA DA MOEDA, S.A.
Rua da Escola Politécnica, 135
1250-100 LISBOA
Tel.: 351 808200110
Fax: 351 213945750
E-mail: dre@incm.pt
Web page address: http://dre.pt
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
Regulation (EC) Number 1935/2004 Decreto-lei nº 175/2007, of 08/05/2007
(replacing Council Directive 89/109/EEC Diário da República, I series, nº 88 of 08/05/2007, p. 2998
and 80/590/EEC) Amend. Decreto-lei nº 378/2007, of 12/11/2007
Diário da República, I series, nº 217 of 12/11/2007, p. 8383
PLASTICS Testing
82/711/EEC (basic rules) Decreto-Lei n° 62/2008 of 31/03/2008
85/572/EEC (simulants) Diário da República, I series, nº 63 of 31/03/2008, p.1833.
93/8/EEC (1st amend. 82/711/EEC)
97/48/EC (2nd amend. 82/711/EEC)
PLASTICS Vinyl chloride monomer
78/142/EEC Decreto-Lei n° 62/2008 of 31/03/2008
80/766/EEC Diário da República, I series, nº 63 of 31/03/2008, p.1833.
81/432/EEC
REGENERATED CELLULOSE FILM
93/ 10/EEC Decreto-lei nº 194/2007, of 14/05/2007
93/111/EEC (1st amend. 93/10/EEC) Diário da República, I series, nº 92 of 14/05/2007, p. 3155
2004/14/EC (2nd amend. 93/10/EEC)
CERAMICS
84/500/EEC Decreto-lei nº 190/2007, of 11/05/2007
2005/31/EC (1st amend. 84/500/EEC) Diário da República, I series, nº 91 of 11/05/2007, p. 3126
RUBBER: N-NITROSAMINES
93/11/EEC Portaria nº 863/94, of 26/09/1994
Diário da República, I series B, nº 223 of 26/09/1994, p. 5794
58 of 71
ADDITIONAL (NON-EC) NATIONAL RECOMMENDATIONS
ENAMELLED WARE
Additional national recommendation Norma Portuguesa NP-2097, de 1986: Esmalte vitrificado em contacto com alimentos.
Limites admissíveis para o chumbo e cádmio. [Portuguese Standard NP-2097 of 1986:
Enamelled ware in contact with food. Permissible limits for lead and cadmium release].
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
59 of 71
ROMANIA
(last update 19/12/2011)
SUMMARY
All EC directives implemented.
Additional national provisions.
Legislation published in the Monitorul Oficial (partea I) [Official Journal]
• Legislation is made under the powers of the of art. 107 of the Constitution
and art. 26 par. (1) of the Emergency
Government Ordinance no. 97/2001 regarding the regulation of food production, circulation and trade,
approved with amendments and additions by means of Law no. 57/2002 .
• Sales Point: Monitorul Oficial al Romaniei
Izvor Street no. 2-4
Sector 5, Bucuresti
Tel: +40 21 490 65 52
www.monitoruloficial.ro
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
89/109/EEC (framework) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
80/590/EEC (symbol) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
PLASTICS Monomers & additives
90/128/EEC (monomer/additive lists) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
92/39/EEC (1st amend. 90/128/EEC) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
93/9/EEC (2nd amend. 90/128/EEC) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
95/3/EC (3rd amend. 90/128/EEC) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
96/11/EC (4th amend. 90/128/EEC) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
99/91/EC (5th amend. 90/128/EEC) DECISION No. 1197 from 24 October 2002
for the approval of the Norms regarding materials and objects coming into
contact with food
2002/72/EC (consolidation Government Decision no. 1.197/2002 for the approval of the Norms regarding
90/128/EEC and its 7 amendments) the materials and objects that come into contact with foodstuffs as amended by
DECISION No. 512 of 7 April 2004
2004/1/EC(1 amend. 2002/72/EC) Government Decision no. 1.197/2002 for approving the Norms concerning the
materials and objects coming into contact with food amended and completed by
DECISION No. 879 from 28 July 2005
2004/19/EC (2nd amend.2002/72/EC)
Government Decision no. 1.197/2002 for approving the Norms concerning the
materials and objects coming into contact with foodstuffs as modified and
completed by the DECISION No. 879 from 28 July 2005
2005/79/EC (3 amend.2002/72/EC) Government Decision no. 1.197/2002 for approving the Norms concerning the
materials and objects coming into contact with food amended and completed by
DECISION No. 1393 from 4 Octomber 2006
2007/19/EC (4 amend. 2002/72/EC) Government Decision no. 1.197/2002 for approving the Norms concerning the
materials and objects coming into contact with food amended and completed by
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
60 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
61 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
62 of 71
SLOVAKIA
(last update 09/09/2010)
SUMMARY
All EC Directives implemented.
Additional national provisions for elastomers and rubber, paper and board, glass, metal and alloys, wood, cork, textile products,
varnishes and coatings.
Legislation published in the
„Vestník Ministerstva pôdohospodárstva Slovenskej republiky”
www.zbierka.sk
Legislation is made under powers of the Ministry of Health and Ministry of Agriculture of the Slovac Republic
Sales Agents : Ministerstvo pôdohospodárstva Slovenskej republiky
Dobrovičova 12
812 60 Bratislava
web site : http://www.mpsr.sk
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS
All EC directives on food contact Výnos Ministerstva pôdohospodárstva Slovenskej republiky a Ministerstva zdravotníctva
materials Slovenskej republiky z 9. júna 2003 č. 1799/2003 – 100, ktorým sa vydáva piata hlava
(89/109 EEC, 80/590/EEC, Potravinového kódexu Slovenskej republiky upravujúca materiály a predmety určené na styk
82/711/EEC, 93/8/EEC, 97/48/EEC, s potravinami.
85/572/EEC, 78/142/EEC, (vydané vo Vestníku MP SR ročník XXXV, čiastka 15 z 3. júla 2003)
80/766/EEC, 81/432/EEC,
93/10/EEC, 84/500/EEC,
2002/72/EC, 2002/16/EC,
93/11/EEC)
Výnos Ministerstva pôdohospodárstva Slovenskej republiky a Ministerstva zdravotníctva
Slovenskej republiky z 8. decembra 2004 č. 14911/2004-OAP, ktorým sa dopĺňa výnos MP
SR a MZ SR č.1799/2003-100 z 9. júna 2003, ktorým sa vydáva hlava Potravinového
kódexu Slovenskej republiky upravujúca materiály a predmety určené na styk s potravinami
(klauzula vzájomného uznávania)
(vydané vo Vestníku MP SR ročník XXXVII, čiastka 5 z 2. februára 2005)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
63 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
64 of 71
SLOVENIA
(last update 04/08/2010)
SUMMARY
All EC Directives implemented.
Additional national provisions for metal, glass, wood, textile, paper and board, rubber and elastomer, colour, glue, varnish,
coating.
Legislation is made under the power of the Act Regulating Health Suitability of Foodstuffs, Articles and Materials Coming into
Contact with Foodstuffs, which fall within the competence of the Ministry of Health.
Published in the Official Gazette of the Republic of Slovenia.
Internet address: http://www.uradni-list.si
Sales Agent : Uradni list Republike Slovenije d.o.o.
Slovenska cesta 9
SI-1001 Ljubljana
Tel: ++386 1 200 18 38
Fax: ++386 1 425 14 18
IMPLEMENTATION OF EC DIRECTIVES
ALL FOOD CONTACT MATERIALS INCLUDING SPECIFIC MATERIALS
Rules on materials and articles intended to come into contact with food (Official Gazette of RS, no. 36/2005 and 100/2006)
FOOD CONTACT PLASTICS
Rules on plastic materials and articles intended to come into contact with food (Official Gazette of RS, no. 65/2008 and 22/2010)
CERAMICS
Rules on ceramic materials intended to come into contact with foodstuffs (Official Gazette of RS, no. 38/2006
TESTING OF FOOD CONTACT MATERIALS
Rules on the testing of material and articles intended to come into contact with foodstuffs (Official Gazette of RS, no. 133/2003)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
65 of 71
SPAIN
(last update 21/12/2011)
SUMMARY
IMPLEMENTATION OF EC DIRECTIVES
PLASTICS Testing
78/142/EEC Real Decreto 866/2008, de 23 de mayo, por el que se aprueba la lista de sustancias
permitidas para la fabricación de materiales y objetos plásticos destinados a entrar en
contacto con los alimentos y se regulan determinadas condiciones de ensayo (BOE de
30/05/2008).
Corrigendum (BOE de 07/06/2008).
82/711/EEC (basic rules) Real Decreto 866/2008, de 23 de mayo, por el que se aprueba la lista de sustancias
93/8/EEC (1st amend.) permitidas para la fabricación de materiales y objetos plásticos destinados a entrar en
97/48/EC (2nd. amend.) contacto con los alimentos y se regulan determinadas condiciones de ensayo (BOE de
30/05/2008).
Corrigendum (BOE de 07/06/2008).
85/572/EEC (simulants) Real Decreto 866/2008, de 23 de mayo, por el que se aprueba la lista de sustancias
2007/19/EC (1st amend.) permitidas para la fabricación de materiales y objetos plásticos destinados a entrar en
contacto con los alimentos y se regulan determinadas condiciones de ensayo (BOE de
30/05/2008).
Corrigendum (BOE de 07/06/2008).
CERAMICS
84/500/EEC Real Decreto 891/2006, de 21 de julio, por el que se aprueban las normas técnico-sanitarias
2005/31/EC (1st amend.) aplicables a los objetos de cerámica para uso alimentario (BOE de 22/07/2006).
Real Decreto 1631/2011, de 14 de noviembre, por el que se modifica el Real Decreto
891/2006, de 21 de julio, por el que se aprueban las normas técnico-sanitarias aplicables a
los objetos de cerámica para uso alimentario.(B.O.E.de 25/11/2011)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
66 of 71
RUBBER: N-NITROSAMINES
93/11/EEC Real Decreto número 1184/1994, de 3 de junio, por el que se establecen las Normas básicas
relativas a la determinación de N-nitrosaminas y de sustancias capaces de convertirse en N-
nitrosaminas (sustancias n-nitrosables) que pueden ceder las tetinas y chupetes de caucho
(BOE de 06/07/1994).
POLYMERS
Resolución de 04/11/1982 de la Subsecretaria para la Sanidad, por la que se aprueba la lista positiva de sustancias destinadas a la
fabricación de compuestos macromoleculares, la lista de migraciones máximas en pruebas de cesión de algunas de ellas, las
condiciones de pureza para las materias colorantes empleadas en los mismos productos y la lista de los materiales poliméricos
adecuados para la fabricación de envases y otros utensilios que puedan estar en contacto con los productos alimenticios y
alimentarios (BOE de 24/11/82), modified by Orden del Ministerio de Sanidad y Consumo de 03/07/1985 (BOE de 12/07/1985).
Real Decreto 847/2011, de 17 de junio, por el que se establece la lista positiva de sustancias permitidas para la fabricación de
materiales poliméricos destinados a entrar en contacto con los alimentos. (B.O.E.de 11/07/2011)
REGENERATED POLYMERS
Real Decreto 846/2011, de 17 de junio, por el que se establecen las condiciones que deben cumplir las materias primas a base de
materiales poliméricos reciclados para su utilización en materiales y objetos destinados a entrar en contacto con alimentos. (B.O.E de.
11/07/2011)
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
67 of 71
SWEDEN
(last update 27/09/2011)
SUMMARY
EC Directives implemented.
Additional national provisions for lead, cadmium, and choking hazards.
Legislation published in the Livsmedelsverkets författningssamling (LIVSFS) [Statute of the Swedish National Food
Administration].
EC Directives implemented by Livsmedelsverkets föreskrifter on material och produkter avsedda att komma i kontakt med
livsmedel [Ordinance of the National Food Administration on materials and articles intended to come into contact with
foodstuffs] LIVSFS 2011:7.
Legislation made under the powers of Livsmedelslagen (2006:804) [The Food Act (2006:804)] and Miljöbalken (1998:808; kap.
14) [The Environmental Act (1998:808); chapter 14].
Sales Agent : National Food Administration Sweden
Box 622, S-751 26 UPPSALA
Tel.: +46-18-175500
Fax: +46-18-105848
E-mail: livsmedelsverket(a)slv.se Web page: www.slv.se
IMPLEMENTATION OF EC DIRECTIVES
All EC Directives are to be found in (the ordinance of the national food administration) LIVSFS 2011:7.
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
68 of 71
UNITED KINGDOM
(last update 21/12/2011)
SUMMARY
All EC Directives have been implemented
No additional national provisions.
Since devolution was introduced in 1999, England, Scotland and Wales have separate legislation. Northern Ireland has had
separate legislation.
Legislation is published by the Stationery Office Limited under the authority of the Office of Public Sector (OPSI). Legislation
issued since 1997 is also published, free-of-charge, on the OPSI website at http://www.opsi.gov.uk
Most legislation is made under the powers of the Food Safety Act 1990, in Great Britain the Food Safety (Northern Ireland)
Order 1991, in Northern Ireland.
• Sales Point: The Office of Public Sector Information (OPSI)
PO Box 29
St Crispins
Duke Street
Norwich NR3 1GN
Tel: 0870 600 5522
Fax: 0870 600 5533
E-mail: london.bookshop(a)tso.co.uk
Website: http://www.opsi.gov.uk
Or: http://www.tsoshop.co.uk/bookstore
IMPLEMENTATION OF EC DIRECTIVES
Directive/ Regulations
Regulation
ALL FOOD CONTACT MATERIALS AND ARTICLES
Regulation (EC) No. The Materials and Articles in Contact with Food (England) Regulations 2007 will be
1935/2004 revoked and remade with necessary amendments by The Materials and Articles in Contact
with Food (England) Regulations 2010 (coming in force date TBA)
Regulation (EC) No. The Plastic Materials and Articles in Contact with Food (England) Regulations
1895/2005 2009
Regulation (EC) No. The Materials and Articles in Contact with Food (England) Regulations 2010
2023/2006
FOOD CONTACT PLASTICS – MONOMERS AND ADDITIVES
2002/72/EC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
2004/1/EC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
(as it applies to plastics defined in 2002/72/EC)
2004/19/EC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
2005/79/EC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
2007/19/EC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
2008/39/EC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
Regulation (EC) No. The Plastic Materials and Articles in Contact with Food (Lid Gaskets) (England)
372/2007 Regulations 2007
Regulation (EC) No. The Plastic Materials and Articles in Contact with Food (England) (Amendment)
597/2008 Regulations 2008
Regulation (EC) No. TBA
282/2008
FOOD CONTACT PLASTICS – TESTING FOR MIGRATION
82/711/EEC The Plastic Materials and Articles in Contact with Food (England) Regulations 2009
93/8/EEC “ “ “ “ “ “
97/48/EC “ “ “ “ “ “
85/572/EEC “ “ “ “ “ “
80/766/EEC “ “ “ “ “
81/432/EEC “ “ “ “ “
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
69 of 71
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.
Part IV: SALES AGENTS
AUSTRIA FINLAND LATVIA
Print Media Austria AG, Verlag Österreich Oy Edita Ab Contact focal point:
Postfach G 7 (Tenschertstraße 7) Hakuninmaantie Gunta.Avotina(a)zm.gov.lv
A-1239 Wien PL 800 00043 EDITA Sarma.Sleze(a)zm.gov.lv
Tel. : +43 1 797 89 DW 294 Helsinki LITHUANIA
Fax : +43 1 797 89 DW 442 Tel. : +358-20 450 2513 http://www3.lrs.lt/DPaieska.html
e-mail : bgbl(a)verlagoesterreich.at Fax : +358-9-5660380
E-mail: asiakaspalvelu(a)edita.fi LUXEMBOURG
Buchhandlung Verlag Österreich http:// www.edita.fi/netmarket Imprimerie de la Cour Victor Buck
Wollzeile 16 6, rue Fr. Hogenberg
A-1010 Wien FRANCE L-1735 Luxembourg
Tel. : +43 1 512 48 85 Direction du Journal Officiel Tel. : 0035 2 49 98 66-1
26, rue Desaix Fax : 0035 2 49 41 64
Manz´sche Verlags- F-75727 Paris Cedex 15
u. Universitätsbuchhandlung Tel. : +33 1 40 58 78 78 MALTA
Kohlmarkt 16 Fax : +33 1 45 79 17 84 Contact focal point:
A-1010 Wien http://www.journal-officiel.gouv.fr ou john.attard-kingswell(a)gov.mt
Tel. : +43 1 531 61 http://www.legifrance.gouv.fr
THE NETHERLANDS
BELGIUM GERMANY Servicecentrum Uitgevers
Moniteur Belge Bundesanzeiger Verlagsges.mbH. Köln PO Box: 20014
Chaussée de Louvain, 40-42 Amsterdamer Str. 192, 50 735 Köln 2500 EA Den Haag
B-1000 Bruxelles Tel.: +49/ –221/ 97668-0 Tel. : +31 70 37 89 880
Tel. : +32 2 552 22 11 Fax: +49/ –221/ 97668-278 Fax : +31 70 37 89 783
http://www.just.fgov.be/cgi/welcome.pl E-mail: vertrieb(a)bundesanzeiger.de E-mail: sdu(a)sdu.nl
WebSite: www.bundesanzeiger.de http://www.sdu.nl
CYPRUS
Government printing office of the GREECE POLAND
Republic of Cyprus National Printery Centrum Obsługi Kancelarii
1445 Nicosia Kapodistriou 34, Prezesa Rady Ministrów
Tel. 00357-22 405801-802 10432 Athens ul. Powsińska 69/71
Fax. 00357-22 303175 Tel.: +30-210-5525713,5249547 02-903 Warszawa
Fax: +30-210-5234312 Tel.: +48/22/ 694 62 96
CZECH REPUBLIK Fax: +48/22/ 694 62 06
Ministerstvo vnitra České republiky HUNGARY E-mail: dziust(a)cokprm.gov.pl
Nad Štolou 936/3, Contact focal point: WebSite: www.cokprm.gov.pl
170 34 Praha 7 Magyar Közlöny Lap- és Könyvkiadó
Holešovice H-1085 Budapest PORTUGAL
Somogyi Béla u. 6. Imprensa Nacional - Casa da Moeda
Tel.: +36 1 266 9290
DENMARK www.mhk.hu Rua da Escola Politécnica, 135
SLOVENIA
ITALY Uradni list Republike Slovenije d.o.o
ESTONIA Istituto Poligrafico e Zecca dello Stato Dunajska cesta 167
Riigi Teataja Kirjastus P.zza G. Verdi, 10 SI-1001 Ljubljana
Lossi plats 1a, 15163 Tallinn Tel.+39.0685081 Tel: ++386 1 200 18 38
Tel. +372 693 5872, +372 693 5866 Fax:+39.0685082517 Fax: ++386 1 425 14 18
E-mail: teataja(a)rtk.ee info(a)uradni-list.si
http://www.riigiteataja.ee http://www.ipzs.it http://www.uradni-list.si
Disclaimer: This document is intended to be used as a working document and the Institutions do not assume any
liability for its content.