Professional Documents
Culture Documents
Samsung Refrigerator DA68-02916A En-12 185
Samsung Refrigerator DA68-02916A En-12 185
user manual
English
Hazards or unsafe
practices that may result
CAUTION
in minor personal injury WARNING
SEVERE WARNING
or property damage. SIGNS FOR
TRANSPORTATION
Do NOT attempt. AND SITE
Do NOT disassemble. • When transporting
and installing the
Do NOT touch. appliance,care should be
Follow directions taken to ensure that no
carefully. parts of the refrigerating
Unplug the power plug circuit are damaged.
from the wall socket. • R-600a or R-134a is used
as a refrigerant. Check the
Make sure the machine
compressor label on the rear
is grounded to prevent
of the appliance or the rating
electric shock.
label inside the refrigerator to
Call the contact center see which refrigerant is used
for help. for your refrigerator.
• When this product contains
Note.
flammable gas (Refrigerant
R-600a),
-- Refrigerant leaking from the
pipe work could ignite or
cause an eye injury. If a leak
is detected, avoid any naked
Safety information _03
INSTALLATION
personal injury.
• Keep ventilation opening • Do not sit on the Freezer door.
in the appliance enclosure
-- The door may be broken and
or mounting structure
cause a personal injury.
clear of obstruction.
• Allow the appliance to stand • Children should be supervised
for 2 hours after installation. to ensure that they do not
play with the appliance. Keep
06_ Safety information
Contents
SETTING UP YOUR FRENCH DOOR REFRIGERATOR………………………… 15
OPERATING YOUR FRENCH DOOR REFRIGERATOR…………………………… 23
TROUBLESHOOTING………………………………………………………………… 36
01 setting up
Congratulations on your purchase of this Samsung
French Door Refrigerator. E
We hope you enjoy the state-of-art features and C D
efficiencies that this new appliance offers.
to swing open.
1125 mm
setting up _15
Allen wrench
Pliers
(5 mm)
16_ setting up
01 setting up
5. Remove the screw ( 8 ) attached to the
lower left and right door hinges with a philips
screwdriver (+). Remove the 2 hex head bolts
( 9 ) attached to the lower left and right door
2. Disconnect the two connectors ( 2 ) on the
hinges with an allen wrench (5 mm). Remove
left side door. To remove the water coupler
the lower left and right door hinges ( 10 ).
from the hinge, twist and pull it from the hinge.
Remove the water line ( 3 ) while pressing the
marked part ( 4 ) of the water line coupler.
10
8
2 9
Allen wrench
3
4
6
5
setting up _17
18_ setting up
01 setting up
CAUTION sliding rail by letting it strike the floor.
Make sure that you mount the freezer
DISASSEMBLING THE CAUTION basket in the right position when removing
RE-ASSEMBLING THE
FREEZER DOOR
4. Press the fixing hook of the rail system. To reattach the drawer after you have moved the
fridge to its final location, assemble the parts in
reverse order.
1
Both control levers must be touching the
3 3
CAUTION floor to avoid possible personal injury or
property damage because of tipping.
20_ setting up
01 setting up
between (A, B & C )
4. Turn water on and check for any leakage.
Water line
CAUTION Loosen a
Remove
cap
The water line must be connected to
the cold water pipe. If it is connected
Water Line
to the hot water pipe, it may cause the from unit
purifier to malfunction.
No gap
Close Main Water Line
Water pipe from Kit
setting up _21
22_ setting up
02 operating
sec for -- To reset the water filter life indicator.
Filter 1) Door Alarm Function
Reset If the door alarm is set to On, an alarm
1 4 beeps if any refrigerator door is left open
for more than three minutes. The beeping
2 5 stops when you close the door. The door
alarm function is pre-set to On in the
3 6 factory. You can turn it off by pressing and
then releasing the Alarm button. You can
10 9 turn it back on in the same fashion. The
7 8 icon lights up when the function is on.
When the Door Alarm function is on and
the alarm sound is triggered, the Door
Alarm Icon will blink while the alarm
sounds.
(1) Touching this button turns Energy Saver
Energy mode on and off. When you turn Energy 2) Water Filter Life Indicator Function
Saver Saver on, the Energy Saver icon lights. After you replace the water filter, touch
Turn Energy Saver off and the icon goes and hold this button for 3 seconds to
off. The Energy Saver function’s factory reset the water filter life indicator. When
setting is “ON”. If condensation or water you reset the water filter life indicator, the
drops appear on the doors, turn the
Filter icon on the panel turns Off. The
Energy Saver mode off.
Filter icon will turn red to let you know it
is time to change the water filter after six
(2) The Freezer button serves two purposes: months (about 300 gallons). Some areas
Freezer -- To set the Freezer to your desired have large amounts of lime in their water,
(Hold 3 temperature. which causes the water filter to clog more
sec for -- To turn the power freeze function on quickly. If this is the case in your area,
Power and off. you will have to change the filter more
Freeze) 1) To set the Freezer temperature frequently than every six months.
Touch the Freezer button to set the
Freezer to your desired temperature. You
can set the temperature between -15 °C
and -23 °C.
operating _23
(5)
(7)
Fridge
Cubed Ice
(Hold 3 The Fridge button serves two purposes: Press the Cubed Ice or Crushed Ice
(8)
sec for -- To set the Fridge to your desired
Crushed button to select the type of ice you want
Power temperature. dispensed.
Ice
Cool) -- To turn the Power Cool function on Each time you press the button, the
and off. cubed and crushed ice modes alternate
1) To set the Fridge temperature and the Cubed or Crushed ice icon lights
Press the Fridge button to set the up, indicating your selection.
refrigerator to the temperature you want. (Cubed) (Crushed)
You can set the temperature between
7 °C and 1 °C.
(9)
2) Power Cool function Ice Off
Touch and hold this button for 3 seconds If you don’t want to make more ice, touch
to decrease the time needed to cool the Ice Off button.
products in the Refrigerator. It can be The icon will light up and the Ice-Maker
helpful if you need to quickly cool easily stops making ice.
spoiled items or if the temperature in We recommend you stop ice
the fridge has warmed dramatically (For making if the following occur:
example, if the door was left open). -- There is enough ice in the ice
bucket.
-- You want to save water and
energy.
-- Water is not being supplied to
the refrigerator.
24_ operating
02 operating
operational after you remove your finger from
the button you pressed.
2. Pull the water filter ( 1 ) from the case filter ( 2 ).
• To change the water filter more easily,
( 10 ) Water filter usage
Filter This icon lights up when you need shut off the water supply valve.
to change the filter, usually after the • Sometimes, it is hard to disassemble the water
refrigerator has dispensed about 300 filter because impurities in the water cause it
gallons of water (after about 6 months). to stick. If you are having difficulties, grip the
The icon will blink red for several seconds water filter firmly and pull it hard.
when you open or close the door.
After you install the new water filter, reset
• When you pull the water filter, a little water
the filter indicator by touching and holding can leak from the opening. This is normal.
the Hold 3sec for Filter Reset button for To minimize the water leaks, keep the filter
3 seconds. cartridge horizontal when you pull it.
-- If water is not dispensing or • To prevent overflow,
dispensing slowly, you need to empty the water 2
replace the water filter because filter tray ( 3 ) and
the water filter is clogged. 3
dry around the filter
-- Some areas have large amounts
of lime in their water, which case ( 2 ).
causes the water filter to clog
more quickly. 3. Insert the new filter into the filter case ( 4 ).
4. Push the filter, and then turn it clockwise until
it locks.
• If you have trouble inserting the water
CHANGING THE WATER filter because of high water pressure,
shut off the water supply valve.
FILTER • The locked symbol should be lined up
To reduce the risk of water damage with the indicator line.
WARNING to your property DO NOT use generic
brands of water filters in your SAMSUNG 4
Refrigerator.
USE ONLY SAMSUNG BRAND
WATER FILTERS. SAMSUNG is not
legally responsible for any damage,
including, but not limited to, property
damage caused by water leakage
(Red) 5. Touch the “Alarm/hold
from the use of a generic water filter.
SAMSUNG Refrigerators are designed to work 3 sec for Filter Reset”
ONLY WITH SAMSUNG Water Filters.
The Filter light turns red to let you know when it is button ( (Filter Reset) ) for
time to change your water filter cartridge. about 3 seconds to reset
To give you time to get a new filter, the red light the water filter. The color of
comes on just before the capacity of the current the indicator ( ) changes from red to off.
filter runs out. Changing the filter on time provides
you with the freshest, cleanest water from your
refrigerator. 6. If you turned off the water supply, turn it back
on.
operating _25
Reverse Osmosis Water Supply The Freezer temperature can be set between
IMPORTANT: -23°C and -15 °C to suit your particular needs.
The pressure of the water supply coming out of a Press the Freezer button repeatedly until the
reverse osmosis system going to the water inlet desired temperature is shown in the temperature
valve of the refrigerator needs to be between 35 display. The temperature will change by 1 °C with
and 120 psi (241 and 827 kPa). each press. See below.
If a reverse osmosis water filtration system is Centigrade : -19 °C ➞ -20 °C ➞ -21 °C ➞ -22 °C
connected to your cold water supply, the water ➞ -23 °C ➞ -15 °C ➞ -16 °C ➞ -17 °C ➞ -18 °C
pressure to the reverse osmosis system needs to ➞ -19 °C.
be a minimum of 40 to 60 psi (276 to 414 kPa.) If Keep in mind that foods like ice cream may melt
the water pressure to the reverse osmosis system at -15.5 °C. The temperature display will move
is less than 40 to 60 psi (276 to 414 kPa): sequentially from -23 °C to -15 °C.
02 operating
Recommend Temp (Fridge) : 3 °C
NO ICE
Select this if you want
to turn ice maker off
The fridge temperature can be set between 1 °C
and 7 °C to suit your particular needs. Press
the Fridge button repeatedly until the desired Using the ice lever ( 1 )
temperature is shown in the temperature display.
The temperature will change by 1 °C with each Push the Ice lever dispenser ( 1 )
press. See below. gently with your glass. Ice will be
released from the dispenser. 1
Centigrade : 3 °C ➞ 2 °C ➞ 1 °C ➞ 7 °C ➞ 6 °C
➞ 5 °C ➞ 4 °C ➞ 3 °C. You can choose the type of ice 2
The temperature control process for the Fridge by pushing the cubed or crushed
works just like the Freezer process. Press the button first.
Fridge button to set your desired temperature.
After a few seconds, the Fridge will begin
adjusting towards the newly set temperature. This Using the Water lever ( 2 )
will be reflected in the digital display. Push the Water lever dispenser ( 2 ) gently with
your glass. Water will be released from the
-- The temperature of the Freezer or Fridge dispenser.
may rise when you open the doors too
frequently, or if a large amount of warm If you push the water and Ice lever
or hot food is placed inside. at about the same time, the dispenser
-- A rise in temperature may cause the digital operates only the option you actually
display to blink. Once the Freezer and selected or pushed first.
Fridge temperature return to their normal set Please wait 1 second before removing
temperatures, the blinking will stop. the cup after dispensing water to prevent
-- If the blinking continues, you may need to spills. Do not pull out the lever dispenser
“reset” the Refrigerator. Try unplugging the after dispensing ice or water. It comes
appliance, wait for around 10 minutes and back automatically.
then plug the power cord back in.
-- If there is a communication error between the
Display and Main Controller, the Convertible
Using the Ice & Water Dispenser
Display light may blink. If the blinking continues
for a long period of time, please contact a together
Samsung Electronics Service Center. To get Ice and water, push the Ice lever ( 1 ) first
for ice, then move your glass down and press the
water dispenser lever ( 2 ) for water.
operating _27
check
the water
level
Test button
28_ operating
02 operating
Then, lift up on the ice bucket, and pull it straight the doors open. Otherwise, odor and mold
out. may develop.
To put the ice bucket back in, push it firmly
straight back.
If the ice bucket is not pushed firmly into Ice Maker Do’s and Don’ts
place, ice in the bucket can melt. • Do not put your fingers, hands or any other
unsuitable objects in the chute or ice-maker
If the bucket does not fit, turn the helix 90 degree bucket
(see the last illustration on the right, below) and try -- It may result in personal injury or material
again. damage.
• Never put your finger or any other objects in
the dispenser opening.
-- It may cause injury.
• Do not try to disassemble the ice maker.
• Do not wash or spray the ice bucket with
water while it is in the refrigerator. Remove it
to clean it.
operating _29
Light
FF Ice-Maker
Foldable-Shelf Fixed-Shelf
Fixed-Shelf
2 Step
Vertical Hinged Foldable-Shelf
Section
Vegetable &
Fruit Drawers
Water Filter Door Bins
Auto Closer
Light
Convertible Room
Auto Closer
Auto Pull Out
Guard Drawer
Freezer Drawer
Bin
When closing the door, make sure the Vertical Hinged Section is in the correct position to avoid
scratching the other door.
If the Vertical Hinged Section is reversed, put it back to the right position and close the door.
Moisture may appear at times on the Vertical Hinged Section.
The door handle may become loose over time. If this happens, tighten the bolts found on the
inside of the door.
If you close one door with too much force, the other door may open.
When the door opens, the interlock switch automatically turns off the auger motor in the ice
maker for safety reasons.
If the interior or exterior LED lamp has gone out, please contact your service agent.
30_ operating
02 operating
3. When “Cold Drinks” is selected, the
temperature of the Flex Zone will be kept
around 1 °C. This feature helps keep drinks
cold and refreshing.
4. When “Meat/Fish” is selected, the
temperature of the Flex Zone will be kept
around -1 °C. This feature helps keep meat or
fish fresh for a longer time.
REMOVING THE 1
REFRIGERATOR ACCESSORIES
2
1. Door Bins
• Door Bins (1)
To remove - Simply lift the bin up and pull
straight out.
To relocate - Slide it in above the desired
location and push down until it stops. 3. Foldable Shelf
• Door Bins (2) To remove - After removing the Shelf Front, lift
To remove - Take the right side of the bin up the Shelf and remove it.
out by lifting it at an angle along the guide, To re-install - Hook the Shelf on the Angle Frame
and then take the left side out by pulling it and re-attach the Shelf Front to the Foldable Shelf.
from the door.
To relocate - Slide it into the original location
and push down until it sticks.
02 operating
• Tilt up the front of the drawer and pull straight
out, and pull out the drawer after moving
slightly in the direction of the arrow.
When the Flex Zone or LED lighting is not 2. Super Extended Drawer
working, check the connectors [ ( 1 ), ( 2 )
shown below ] for cracks or leaks. To remove - Pull the drawer out to full extension.
operating _33
3. Freezer Drawer
To remove the freezer drawer - Pull the freezer CLEANING THE
drawer out fully. Tilt up the rear of the bin and lift it REFRIGERATOR
out to remove.
To re-install the freezer drawer - Place the bin Caring for your Samsung French Door Refrigerator
into the rail assembly. prolongs its life and helps keep it free of odor and
germs.
You can scratch the side of the bin if you Cleaning the Interior
CAUTION twist it left or right when disassembling or
Clean the inside walls and accessories with a mild
re-assembling it.
detergent and then wipe dry with a soft cloth. You
can remove the drawers and shelves for a more
Do not allow babies or children go inside
thorough cleaning. Just make sure to dry drawers
CAUTION the freezer drawer. They could damage
and shelves before putting them back into place.
the refrigerator and seriously injure
themselves. Do not sit on the freezer door.
The door may break. Do not allow children
to climb into the freezer drawer.
CAUTION
Do not remove the divider.
34_ operating
02 operating
1
apply stainless cleaner directly
to the area where the letters
are printed.
operating _35
36_ Troubleshooting
03 Troubleshooting
• Is the freezer drawer closed properly?
Water • Is the water line connected and the shut-off valve opened?
dispenser is not • Has the water supply line tubing been crushed or kinked?
functioning. • Make sure the tubing is free and clear of any obstruction.
• Is the water tank frozen because the fridge temperature is too low?
Try selecting a warmer setting on the Digital display.
• Is the Child Lock on?
Auto close • Is there an imbalance between the right and left parts of the door?
system does • Open and close the door smoothly 1~2 times. After you do this, the auto
not work with close system usually works properly again.
the freezer • Try opening the door smoothly to avoid unbalancing the right part and the
door. left part of the door.
Troubleshooting _37
Internal temperatures may be affected by such factors as the location of the fridge/freezer,
ambient temperature and the frequency with which you open the door.
Adjust the temperature as required to compensate for these factors.
Correct Disposal of This Product
(Waste Electrical & Electronic Equipment)
English
(Applicable in countries with separate collection systems)
This marking on the product, accessories or literature indicates that the product and its electronic
accessories (e.g. charger, headset, USB cable) should not be disposed of with other household
waste at the end of their working life. To prevent possible harm to the environment or human health
from uncontrolled waste disposal, please separate these items from other types of waste and recycle
them responsibly to promote the sustainable reuse of material resources.
Household users should contact either the retailer where they purchased this product, or their local
government office, for details of where and how they can take these items for environmentally safe
recycling.
Business users should contact their supplier and check the terms and conditions of the purchase
contract. This product and its electronic accessories should not be mixed with other commercial
wastes for disposal.
DA68-02916A-12