Professional Documents
Culture Documents
Design Calculation Report For Lazaro
Design Calculation Report For Lazaro
MR.&MRS.LAZARO/TRINIDAD
RODRIGUEZ
STRUCTURAL DESIGN
CALCULATION
(NOV 2018)
1
GENERAL ...........................................................................................
................................. 2
1.1
SCOPE .......................................................................................................................
......... 2
1.2 UNITS OF
MEASUREMENTS ............................................................................................. 2
REFERENCES .............................................................................................. 2
1.4 MATERIAL
PROPERTIES ................................................................................................... 2
INFORMATION. ............................................................................................. 2
GEOMETRY…………….................................................................. 3
3 DESIGN PHILOSOPHY.
………........................................................................................................... 3
CALCULATIONS............................................................................................. 3
…................................................................................................... 3
(LL) .......................................................................................................... 3
(E) .................................................................................................... 3
3.1.4 WIND
LOAD .............................................................................................................. 3
4 ANALYSIS OF STRUCTURE.
………….................................................................................................. 5
…….................................................................................................... 5
….................................................................................................. 5
1 GENERAL
1.1 SCOPE
This Document Covers Anaysis and Design of 2 STOREY RESIDENTIAL BULDING.
1.2 UNITS OF MEASUREMENTS
Units of measurements used in analysis shall be of SI Units.
1.3 CODES AND REFERENCES
Project Reference Drawings / Documents
1 General Notes for Structures & Foundations
2 Site Development Plan
Codes & Standards
4 ASCE 7-05 Minimum Design Loads for Buildings and Other Structures
5 NSCP 2010 National Structural Code of the Philippines 2010
6 ACI-318 Building Code Requirements for Structural Concrete and Commentary
7 AISC 2005
1.4 MATERIAL PROPERTIES
Material Property Value Units
a. Concrete Fc 21 MPA
Density 24 kN/cum
Compressive Strength of Concrete, fc 21 N/sq mm
Modulus o f Elasticity of Concrete , Ec 21538 N/sq mm
b. Intermediate Strength Reinforcing Steel Grade 40 for Ties, Stirrups for Stiffener
Beams and Columns.
c. High Strength Reinforcing Steel Grade 60 for Top and Bottom Bars for Main
Beams and Vertical Bars for Columns.
Density 78.5 kN/cum
Yield Strength, Fy (Below 12mm) Grade 275 N/sq mm
Yield Strength, Fy (Greater than 12mm) Grade 414 N/sq mm
Modulus of Elasticity 210000 N/sq mm
Structural Steel,ASTM A36
Density 78.5 kN/cum
Characteristic Strength 248 N/sq mm
3 DESIGN PHILOSOPHY
The analysis was performed for loads namely, self-weight of structural
members, , live loads, seismic and wind loads using STAAD. A 3D-model is
prepared in STAAD with all the main frame members. Structural members are
designed as per ACI 318 and AISC 360 on Equivalent Lateral Force Analysis
method . Various possible load combinations of the primary loads are
considered and these are listed in Staad Calculation.
Load calculations :
a. Unit weights of materials :
b. Cement concrete = 24.0 kN/m3
c. Hollow Concrete Block = 21.0 kN/m3